hcd-ex99

Transcrição

hcd-ex99

HCD-EX66/EX88/EX99
SERVICE MANUAL
E Model
Ver. 1.0 2011.03
• HCD-EX66 is the amplifier, USB, CD player
and tuner section in MHC-EX66.
Photo: HCD-EX99
• MPEG Layer-3 audio coding technology and patents licensed from
Fraunhofer IIS and Thomson.
• Windows Media is either a registered trademark or trademark of Microsoft
Corporation in the United States and/orother countries.
• This product contains technology subject to certain intellectual property
rights of Microsoft. Use or distribution of this technology outside of this
product is prohibited without the appropriate license(s) from Microsoft.
Model Name Using Similar Mechanism
CD Section
New
Mechanism Type
CDM76B-D1BD76
Optical Pick-up Block Name
DA11MMVGP
SPECIFICATIONS
Amplifier section
Inputs
CD player section
The following measured at AC 127 V,
60 Hz (Mexican model)
50/60 Hz (Argentine model)
50/60 Hz (Other models)
DVD/PC IN L/R (phono jacks):
Sensitivity 700 mV, impedance
22 kΩ
System:
HCD-EX99
Front Speaker:
Power output (rated):
80 W + 80 W (at 3 Ω, 1 kHz, 1% THD)
RMS output power (reference):
135 W + 135 W (per channel at 3 Ω,
1 kHz)
Subwoofer:
200 W (at 8 Ω, 100 Hz)
HCD-EX88
120 W + 120 W (at 4 Ω, 1 kHz, 1% THD)
1 kHz)
HCD-EX66
50 W + 50 W (at 4 Ω, 1 kHz, 1%
THD)
1 kHz)
Outputs
PHONES (stereo mini jack):
accepts headphones with an
impedance of 8 Ω or more
SPEAKERS: impedance
HCD-EX99: impedance 3 Ω
HCD-EX88/EX66: impedance 4 Ω
SUBWOOFER (HCD-EX99 only):
impedance 8 Ω
USB section
Supported bit rate:
MP3 (MPEG 1 Audio Layer-3):
32 kbps – 320 kbps, VBR
WMA: 48 kbps – 192 kbps
AAC: 48 kbps – 320 kbps
Sampling frequencies:
MP3 (MPEG 1 Audio Layer-3):
32/44.1/48 kHz
WMA: 44.1 kHz
AAC: 44.1 kHz
(USB) port:
Maximum current:
500 mA
Compact disc and digital audio
system
Laser Diode Properties
Emission Duration: Continuous
Laser Output*: Less than 44.6μW
* This output is the value
measurement at a distance of
200mm from the objective lens
surface on the Optical Pick-up
Block with 7mm aperture.
Frequency response: 20 Hz – 20 kHz
Signal-to-noise ratio: More than 90 dB
Dynamic range: More than 88 dB
Tuner section
FM stereo, FM/AM superheterodyne tuner
Antenna:
FM lead antenna
AM loop antenna
FM tuner section:
Tuning range:
87.5 MHz ‒ 108.0 MHz (50 kHz step)
Intermediate frequency:
200/250/300/350/400 kHz
– Continued on next page –
COMPACT DISC RECEIVER
9-893-153-01
2011C04-1
© 2011.03
Sony Corporation
Published by Sony Techno Create Corporation
HCD-EX66/EX88/EX99
AM tuner section:
Tuning range
Latin American models:
530 kHz ‒ 1,710 kHz (10 kHz step)
531 kHz ‒ 1,710 kHz (9 kHz step)
Saudi Arabia model:
Other models:
530 kHz ‒ 1,610 kHz (10 kHz step)
Intermediate frequency: 400 kHz
General
Power requirements
Mexican model:
AC 127 V, 60 Hz
Argentine model:
AC 220 V ‒ 240 V, 50/60 Hz
Other models:
AC 120 V ‒ 240 V, 50/60 Hz
Power consumption
HCD-EX99: 85 W
(0.5 W at the Power Saving Mode)
HCD-EX88: 70 W
HCD-EX66: 45 W
Dimensions (W/H/D) (excl. speakers)
Approx. 210 mm × 312 mm ×
375 mm
Mass (excl. speakers)
HCD-EX99/EX88: Approx. 3.8 kg
HCD-EX66: Approx. 3.6 kg
NOTES ON CHIP COMPONENT REPLACEMENT
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be damaged by heat.
FLEXIBLE CIRCUIT BOARD REPAIRING
• Keep the temperature of soldering iron around 270 °C during
repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation exposure.
This appliance is classified as
a CLASS 1 LASER product.
This marking is located on the
rear exterior.
Design and specifications are subject to
change without notice.
SAFETY-RELATED COMPONENT WARNING!
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE
WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
2
HCD-EX66/EX88/EX99
TABLE OF CONTENTS
1.
SERVICING NOTES .............................................
2.
DISASSEMBLY
2-1.
2-2.
2-3.
2-4.
2-5.
2-6.
2-7.
2-8.
2-9.
2-10.
Side Case (L), Side Case (R) .........................................
Top Panel Section ...........................................................
Shield (Power-PWB) ......................................................
Front Panel Section .........................................................
Back Panel Section .........................................................
AMP SMPS Board ..........................................................
Knob (VOL) ....................................................................
CD Mechanism Deck ......................................................
Base Unit.........................................................................
Optical Pick-up ...............................................................
3.
TEST MODE ............................................................ 15
4.
ELECTRICAL ADJUSTMENTS ........................ 16
5.
DIAGRAMS
5-1.
5-2.
5-3.
5-4.
5-5.
5-6.
5-7.
5-8.
5-9.
5-10.
5-11.
5-12.
5-13.
5-14.
5-15.
Block Diagram –CD Section– ........................................
Block Diagram –Tuner/Audio Section– .........................
Block Diagram –Display/Power Section– ......................
Printed Wiring Board –CD Section– ..............................
Schematic Diagram –CD Section (1/2)– ........................
Schematic Diagram –CD Section (2/2)– ........................
Printed Wiring Board –Panel Section– ...........................
Schematic Diagram –Panel Section (1/3)– .....................
Schematic Diagram –Tuner Section– .............................
Printed Wiring Board –Tuner Section–...........................
Printed Wiring Board –Module Section–........................
Schematic Diagram –Module Section– ..........................
Printed Wiring Board
–AMP SMPS Section (HCD-EX66)– .............................
4
9
9
10
10
11
12
13
13
14
14
17
18
19
21
22
23
24
25
26
27
28
29
29
30
5-16. Schematic Diagram
–AMP SMPS Section (1/2) (HCD-EX66)– ....................
5-18. Printed Wiring Board
–Regulator Section (HCD-EX88)– .................................
32
33
34
35
36
37
38
39
40
41
42
43
6.
EXPLODED VIEWS
6-1.
6-2.
6-3.
6-4.
Overall Section ...............................................................
Front Panel Section .........................................................
Top Panel Section ...........................................................
Chassis Section ...............................................................
7.
ELECTRICAL PARTS LIST .............................. 55
51
52
53
54
Accessories are given in the last of the electrical parts list.
31
3
HCD-EX66/EX88/EX99
SECTION 1
SERVICING NOTES
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic break-down because of the potential difference generated by
the charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
MODEL IDENTIFICATION
– Model Number Lavel –
Parts No.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused
on the disc reflective surface by the objective lens in the optical
pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
UNLEADED SOLDER
Boards requiring use of unleaded solder are printed with the leadfree mark (LF) indicating the solder contains no lead.
(Caution: Some printed circuit boards may not come printed with
the lead free mark due to their particular size)
: LEAD FREE MARK
Unleaded solder has the following characteristics.
• Unleaded solder melts at a temperature about 40 °C higher
than ordinary solder.
Ordinary soldering irons can be used but the iron tip has to be
applied to the solder joint for a slightly longer time.
Soldering irons using a temperature regulator should be set to
about 350 °C.
Caution: The printed pattern (copper foil) may peel away if
the heated tip is applied for too long, so be careful!
• Strong viscosity
Unleaded solder is more viscous (sticky, less prone to flow)
than ordinary solder so use caution not to let solder bridges
occur such as on IC pins, etc.
• Usable with ordinary solder
It is best to use only unleaded solder but unleaded solder may
also be added to ordinary solder.
RELEASING THE DISC TRAY LOCK
The disc tray lock function for the antitheft of an demonstration
disc in the store is equipped.
Releasing Procedure:
1. Press [?/1] button to turn the power on.
2. Press the [FUNCTION] button to select CD function.
3. While pressing the [x] button for more 5 seconds.
4. The message “CHILD LOCK OFF” is displayed and the disc
tray is unlocked.
Note: When “CHILD LOCK ON” is displayed, the slot lock is not released by turning power on/off with the [?/1] button.
4
Model
Part No.
EX99: MX model
4-263-771-0[]
EX99: AR model
4-263-772-0[]
EX88: E2, E51 models
4-263-773-0[]
EX88: MX model
4-263-774-0[]
EX88: AR model
4-263-775-0[]
EX66: E4 model
4-263-778-0[]
EX66: EA model
4-263-779-0[]
4-263-780-0[]
EX66: AR model
4-263-782-0[]
*
• Abbreviation
AR
: Argentina model
E2
: 120V AC area in E model
E4
: 220 – 240V AC area in E model
E51 : Chilean and Peruvian models
EA
: Saudi Arabia model
MX
: Mexican model
*: Since the HCD-EX99: E2 and E51 models have their model
number labels marked directly on the back panel, the model
number labels have no relative part numbers.
Because of this, determine the model through the marked model
number when comparing the difference between these models.
HCD-EX66/EX88/EX99
SERVICE POSITION OF CDM76
top panel section
BD76 board
stand
SERVICE POSITION OF BOARDS
PANEL board
tuner unit
(TUNER board)
AMP SMPS board
5
HCD-EX66/EX88/EX99
HOW TO OPEN THE TRAY WHEN POWER SWITCH TURN OFF
pin
bracket
Pull the tray by the hand.
CAPACITOR DISCHARGE FOR ELECTRIC SHOCK PREVENTION
AMP SMPS board
In checking the AMP SMPS board, make a capacitor
discharge of C624 (EX66) or C625 (EX88) or C631
(EX99) and C914 for electrical shock prevention.
800 :/2 W
AMP SMPS board
(Right side view)
C624 (EX66)
C625 (EX88)
C631 (EX99)
800 :/2 W
6
C914
HCD-EX66/EX88/EX99
PRECAUTION WHEN INSTALLING A NEW OP UNIT/
PRECAUTION BEFORE UNSOLDERING THE STATIC
ELECTRICITY PREVENTION SOLDER BRIDGE
When installing a new OP unit, be sure to connect the flexible
printed circuit board first of all before removing the static electricity prevention solder bridge by unsoldering.
Remove the static electricity prevention solder bridge by unsoldering after the flexible printed circuit board has already been connected.
(Do not remove nor unsolder the solder bridge as long as the OP
unit is kept standalone.)
7
HCD-EX66/EX88/EX99
SECTION 2
DISASSEMBLY
•
This set can be disassembled in the order shown below.
SET
8
2-1.
SIDE CASE (L),
SIDE CASE (R)
(Page 9)
2-2.
TOP PANEL SECTION
(Page 9)
2-3.
SHIELD (POWER-PWB)
(Page 10)
2-4.
FRONT PANEL SECTION
(Page 10)
2-5.
2-7.
KNOB (VOL)
(Page 13)
2-6.
2-8.
CD MECHANISM DECK
(Page 13)
BACK PANEL SECTION
(Page 11)
2-9.
BASE UNIT
(Page 14)
AMP SMPS BOARD
(Page 12)
2-10. OPTICAL PICK-UP
(Page 14)
HCD-EX66/EX88/EX99
Note: Follow the disassembly procedure in the numerical order given.
2-1.
SIDE CASE (L), SIDE CASE (R)
2 two screws
(case 3 TP2)
5
two claws
3 three screws
(+BVTP 3 u10)
6 side case (L)
4
two claws
qa
8 two screws
(case 3 TP2)
1 two screws
(case 3 TP2)
0
9 two screws
(+BVTP 3 u10)
qs side case (R)
2-2.
7 two screws
(case 3 TP2)
TOP PANEL SECTION
5 two screws
(+BVTP 3 u10)
7 two hooks
8 top panel section
6
2 wire (flat type) (5 core)
(CN302)
4 screw
(+BVTP 3 u10)
(CN401)
3 screw
(+BVTP 3 u10)
9
HCD-EX66/EX88/EX99
2-3.
SHIELD (POWER-PWB)
1 screw
(+BVTP 3 u10)
2 wire
4 two screws
(+BVTP 3 u10)
7 shield (power-PWB)
3 screw
(+BVTP 3 u10)
5 two screws
(+BVTP 3 u10)
6
2-4.
FRONT PANEL SECTION
(CN501)
4 front panel section
claw
claw
(CN600) (EX66/EX88)
wire (flat type) (23 core)
(CN600) (EX99)
3 three screws
(+BVTP 3 u10)
10
HCD-EX66/EX88/EX99
2-5.
BACK PANEL SECTION
EX88/EX99
3 screw
(+BVTP 3 u10)
(CN501)
4 cover (power-PWB)
2 screw
(+BVTP 3 u10)
5 CN701 (3P) (EX88)
CN702 (3P) (EX99)
7 screw
(+BVTP 3 u10)
8 back panel section
6 CN901 (2P)
EX66
3 screw
(+BVTP 3 u10)
(CN501)
4 cover (power-PWB)
2 screw
(+BVTP 3 u10)
5 CN700 (3P)
7 screw
(+BVTP 3 u10)
8 back panel section
6 CN901 (2P)
11
HCD-EX66/EX88/EX99
2-6.
AMP SMPS BOARD
EX88/EX99
9 REGULATOR board
8 two screws
(+BVTP 3 u10)
6 three screws
(+BVTP 3 u10)
EX99
3 three screws
(+BVTP 3 u10)
2 screw
(+BVTP 3 u10)
(CN600) (EX88)
wire (flat type) (23 core)
(CN600) (EX99)
4 bracket (SP08)
5 six screws
(+BVTP 3 u10)
0 AMP SMPS board
7
EX88
3 two screws
(+BVTP 3 u10)
2 screw
(+BVTP 3 u10)
4 bracket (SP08)
EX66
6 three screws
(+BVTP 3 u10)
7 AMP SMPS board
3 two screws
(+BVTP 3 u10)
2 screw
(+BVTP 3 u10)
4 bracket (SP08)
(CN600)
12
5 six screws
(+BVTP 3 u10)
HCD-EX66/EX88/EX99
2-7.
KNOB (VOL)
2 knob (VOL)
front panel block
(back view)
hole
1 Push the knob (VOL) by flat-head screwdriver.
2-8.
CD MECHANISM DECK
4 two screws
(+P tapping (B2.6))
5 top lid
4 two screws
(+P tapping (B2.6))
7 CD mechanism deck block
2
3 top panel
1 four screws
(+BVTP 3 u10)
13
HCD-EX66/EX88/EX99
2-9.
BASE UNIT
2 two screws
(+BVTP 2.6 (3CR))
4 two coil springs (insulator)
1 two floating screws
(+PTPWH M2.6)
3 two stoppers (BU)
4 two coil springs (insulator)
6 two insulators
7 base unit
6 two insulators
5
top panel block
(bottom view)
2-10. OPTICAL PICK-UP
3 optical pick-up
(CN201)
4 BD76 board
1 Remove the four solders.
14
HCD-EX66/EX88/EX99
SECTION 3
TEST MODE
COLD RESET
The cold reset clears all data including preset data stored in the
memory to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. In the standby status, press the [?/1] button to turn the power
on.
2. Press three buttons of [x], [FUNCTION] and [?/1] simultaneously.
3. When “RESET” appears, the set enters standby status.
PANEL TEST MODE
Enter The Panel Test Mode
Procedure:
1. In the standby status, press the [?/1] button to turn the power
on.
2. Press three buttons of [x], [OPTIONS] and [?/1] simultaneously.
3. When the panel test mode is activated, all LEDs and segments
of the liquid crystal display panel are all turned on.
Version Check
Procedure:
1. In the panel test mode (all LEDs and segments of the liquid
crystal display panel are turned on), press the [FUNCTION]
button.
2. On the liquid crystal display panel, date and version are displayed “xxxxVxxx”.
3. From this status, press the [u] button, and the destination and
model name are displayed.
4. To release from this mode, press three buttons of [x], [OPTIONS] and [?/1] simultaneously.
Key Test Mode
Procedure:
1. In the panel test mode (all LEDs and segments of the liquid
crystal display panel are turned on), press the [x] button.
2. The message “KEY0 0 0” displayed. Whenever any buttons
are pressed and the [VOLUME] control is turned, the value is
changed.
3. To release from this mode, press three buttons of [x], [OPTIONS] and [?/1] simultaneously.
CD TRAY LOCK
This mode is for the antitheft of CD disc in shop. (not for transport)
Procedure:
1. Press the [?/1] button to turn the power on.
3. Insert a disc.
4. While pressing the [x] button for more 5 seconds.
5. The message “CHILD LOCK ON” is displayed and the disc
tray is locked. (Even if releasing from this mode, the disc tray
is still locked)
6. If press the [Z] button to eject the disc, the message “CHILD
LOCK” is displayed and can not eject the disc.
7. To release this lock, while pressing the [x] button for 5 seconds again.
8. The message “CHILD LOCK OFF” is displayed and the disc
tray is unlocked.
CD POWER MANAGE
This mode is for switch the CD power supply on/off. Even if this
state pulls out AC plug, it is held.
Procedure:
3. Press the [?/1] button again to turn the power off (clock
mode).
4. After pressing the [DISPLAY] button on the remote commander, while pressing the [x] button, press the [?/1] button.
5. It turns power on and display “CD/USB”, then display “PWR
ON” or “PWR OFF”.
CHANGE-OVER THE AM TUNING INTERVAL
The AM tuning interval can be changed over 9 kHz or 10 kHz.
Procedure:
2. Press the [FUNCTION] button to select TUNER AM function.
3. Press the [?/1] button again to turn the power off (clock
mode).
4. After pressing the [DISPLAY] button on the remote commander, while pressing the [TUNING + M L] button,
press the [?/1] button.
5. It turns power on and display “9k STEP” or “10k STEP”, and
thus the tuning interval is changed over.
CD SHIP MODE
This mode can run the CD sled motor optionally. Use this mode,
for instance, when cleaning the optical pick-up.
Procedure:
2. Confirm there is no disc in tray.
4. Press two buttons of [x] and [?/1] simultaneously.
5. Set to the CD ship mode (chucking on).
6. After blink “STANDBY”, “CHILD LOCK ON” is displayed,
disconnect the AC plug.
CD SHIP AND COLD RESET
Procedure:
2. Confirm there is no disc in tray.
4. Press three buttons of [ENTER], [TUNING– l m] and
[?/1] simultaneously.
5. After blink “STANDBY”, “RESET” is displayed, disconnect
the AC plug.
15
HCD-EX66/EX88/EX99
SECTION 4
ELECTRICAL ADJUSTMENTS
CD SECTION
TUNER SECTION
Note:
1. CD Block is basically constructed to operate without adjustment.
2. Use YEDS-18 disc (Part No. 3-702-101-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10 MΩ impedance.
4. Clean the object lens by an applicator with neutral detergent when the
signal level is low than specified value with the following checks.
5. Check the focus bias check when optical pick-up block is replaced.
0 dB = 1 μV
FM AUTO STOP CHECK
signal
generator
set
+
75 :
FOCUS BIAS CHECK
–
oscilloscope
(DC range)
BD76 board
CL102 (RFOUT)
CL117 (VREF)
Procedure:
1. Turn the power on.
2. Input the following signal from Signal Generator to FM antenna input directly.
+
–
Procedure:
1. Connect the oscilloscope to CL102 (RFOUT) and CL117
(VREF) on the BD76 board.
2. Press the [?/1] button to turn the power on, and press the
[FUNCTION] button to select CD function.
3. Set disc (YEDS-18) and press the [u] button to playback.
4. Confirm that oscilloscope waveform is as shown in the figure
below (eye pattern).
A good eye pattern means that the diamond shape (◊) in the
center of the waveform can be clearly distinguished.
VOLT/DIV: 200 mV
TIME/DIV: 500 ns
level:
1.1 ± 0.4 Vp-p
Checking Location:
– BD76 Board (Side B) –
CL102
(RFOUT)
IC101
CL117
(VREF)
16
Carrier frequency : A = 87.5 MHz, B = 98 MHz, C = 108 MHz
Deviation
: 75 kHz
Modulation
: 1 kHz
ANT input
: 35 dBu (EMF)
Note: Please use 75 ohm “coaxial cable” to connect SG and the set. You
cannot use video cable for checking.
Please use SG whose output impedance is 75 ohm.
3. Set to FM tuner function and scan the input FM signal with
automatic scanning.
4. Confirm that input Frequency of A, B and C detected and automatic scanning stops.
The stop of automatic scanning means “The station signal is received in good condition”.
HCD-EX66/EX88/EX99
SECTION 5
DIAGRAMS
5-1.
BLOCK DIAGRAM –CD Section –
USB CONTROLLER
IC901
DBGP0
DBGP1
DBGP2
DBGP0 23
DBGP1 24
DBGP2 25
CN304
3
D+
2
D-
38 UHD+
37 UHD-
1
(USB)
VBUS+5V
4
6 CF1
X901
12MHz
7 CF2
5
7
6
8
13
14
A
B
C
D
E
F
AUTOMATIC
POWER
CONTROL
Q201
LD
AIN
BIN
CIN
DIN
EIN
FIN
18 LDD
CN901
FLASH
(PROGRAMMING
)
44
45
47
2
9
10
11
15
32
26
27
28
31
33
46
TRESET
9
R-FK LV RPLWWHG GXH WR VDPH DV L-FK.
SLJQDO SDWK
: CD
: USB
(Page 18)
CD-MP3 PROCESSOR
IC101
OPTICAL PICK-UP BLOCK
(DA11MMVGP)
TUNER/
AUDIO
SECTION
LCHO 76
RCHO 78
CD/USB-L
R-CH
A
93
94
92
4
O-USB-TXD
I-USB-RXD
O-USB-SLEEP
O-USB-RST
+9V
STREQ
STCK
STDATA
PCMLRSY
PCMBCK
PCMDATA
PCMREQ
33
34
35
62
63
64
65
SYSTEM CONTROL
IC302 (1/3)
11 VREF
VREF
2
1
11
12
18
17
26
27
VO1+
VO1VO2+
VO2VO3+
VO3VO4+
VO4-
CE 43
IN2’ 9
24 SLDO
XOUT 72
XIN 73
IN3’ 20
23 TDO
IN4’ 24
22 FDO
MUTE 7
3
98
99
2
O-CD-CE
O-CD-CL
I-CD-DO
O-CD-DI
DVDD3.3V
O-CD-ON 91
O-CD-M- 87
O-CD-M+ 88
RESB 47
7 FIN
9 RIN
LOADING
MOTOR
DRIVE
IC303
CD
MECHANISM
DECK
M+
OUT2 2
OUT1 4
M–
OPEN SW
LIMIT-SW 32
25 SPDO
AVDD3.3V
4
1
VREF
DO 46
IN1 3
+3.3V REG
IC304
MOTOR
CONTROL
Q305
CL 44
DI 45
FOCUS/TRACKING COIL DRIVE,
SLED/SPINDLE MOTOR DRIVE
IC301
2
1
19 LDS
MD
SP+
SPSL+
SLT+
TF+
F-
URX1
UTX1
P71
RES
SO0
SI0
SCK0
P16
P23
SDAT
BCLK
LRCK
P22
P24
P70
8
7
5
I-CD-OP/CL 18
S001
(LIMIT)
CLOSE SW
X101
16.934MHz
I-HP/CD-SW
1 O-CD-RST
DBGP0
DBGP1
DBGP2
DBGP0 95
DBGP1 96
DBGP2 97
5
RESET
I-RST
C
1
DISPLAY/POWER
SECTION
(Page 19)
HCD-EX66/EX88/EX99
17
17
CN301
FLASH
(PROGRAMMING
)
I-RST 11
TUNER/
AUDIO
SECTION
(Page 18)
2
3
100 O-CD-M-MUTE
B
HCD-EX66/EX88/EX99
BLOCK DIAGRAM –TUNER/AUDIO Section –
INPUT FUNCTION SELECTOR
IC306
CD SECTION
(Page 17)
L
5
FL501
BAND-PASS
FILTER
3
CD SECTION
ROUT 14
2
7 ARF2
L501
R-CH
13
10
8
X2 19
MUTE
Q325
5 TUNER-R
SUBWOOFER
AMP
Q312-315
VACS/SIGNAL LEVEL
CONTROL
IC305
X501
32.768kHz
SEL-L 11
SEL-R 12
3
1
5
7
5
SUBWOOFER
MUTE
Q311,316,317
EX99
OUT_A 52
5 INPUT_B
1
TB601
OUT_A 53
+
OUT_B 44
– ,03('$1&(86(ȍ
OUT_B 45
PRE AMP
IC601
5
27 SCLK
I-HP/CD-SW
R-CH
4 INPUT_A
7
2
B
POWER AMP
IC800
PRE AMP
IC600
X1 18
6 ARF1
1
R-CH
(Page 17)
MUTE
CONTROL
Q321,324
9 PC-IN-R
J302
PHONES
R-CH
R-CH
6 TUNER-L
LOUT 15
4 FRF1
+9V
7
AM/FM-DET,OSC,MIX,PLL,IF AMP
IC502
I2C/RDSI
AM
R-CH
R-CH
CK
AM
OUT-L 21
10 PC-IN-L
DA
ANTENNA
FM/AM
7 CD/USB-R
OUT-R 25
J301
-1
R
FM
R-CH
+8.3V REG
Q319
8
VCC
8 CD/USB-L
CD/USB-L
-2
DVD/PC IN
CN502
A
HEADPHONE
AMP
IC308
7
10 INPUT_C
R-CH
28 SDATA
11 INPUT_D
RESET
SD
5-2.
SUBWOOFER
TB600
OUT_C 36
+
OUT_C 37
–
L
SPEAKERS
+ ,03('$1&(86(ȍ
R
–
OUT_D 28
OUT_D 29
2 5
1
2
9V
+3.3V REG
IC501
5
+3.3V(TU)
DISPLAY/
POWER
SECTION
ISYSTEM CONTROL
IC302 (2/3)
D
PROTECT-F
(Page 19)
DC DETECT
Q706
SPEAKER RELAY
DRIVER
Q705
D324
6 I2C-FUNC-DATA
7 I2C-FUNC-CLK
I-SIGNAL-LEVEL 21
I-LED-LEVEL 22
I-VACS 23
D319
PRE AMP
IC600 (EX66)
IC600 (EX88)
41 I-RDSI
9 I2C-TU-CLK
RY600
POWER AMP
IC800 (EX66)
IC800 (EX88)
PRE AMP
IC601 (EX66)
IC601 (EX88)
EX66/EX88
6
7
6
7
5 INPUT_B
OUT_A 52
4 INPUT_B
5FKLVRPLWWHGGXHWRVDPHDV/FK
6LJQDOSDWK
R-CH
10 INPUT_C
R-CH
11 INPUT_D
OUT_A 53
SPEAKERS
OUT_C 36
,03('$1&(86(ȍ
1
OUT_D 28
OUT_D 29
D601
2 15
: FM
2
OUT_C 37
RESET
SD
O-FR-RELAY 31
OVERLOAD
DETECT
Q604-607
: AM
O-AMP-RST 33
DC DETECT
Q705
: DVD
FAN MOTOR CONTROL
Q706,707,712 (EX66)
Q608,706,707 (EX88)
Q707,708,712 (EX99)
O-FAN-LOW-SPEED 30
+13V
DC DETECT
Q711
D704
+9V
M+7V
18
FAN MOTOR
REG
Q708 (EX66/EX88)
Q709 (EX99)
FAN MOTOR
DETECT
Q709 (EX66/EX88)
Q710 (EX99)
I-PROTECT-S 35
18
+
3 – L
OUT_B 45
O-SW-MUTE 32
HCD-EX66/EX88/EX99
TB600
4
OUT_B 44
O-HP-MUTE 36
8 I2C-TU-DATA
: CD
OVERLOAD
DETECT
Q604-607,
609,610
+
FAN701
DC FAN
–
+
–
R
HCD-EX66/EX88/EX99
5-3.
BLOCK DIAGRAM –DISPLAY/POWER Section –
T901
RECT DC-DC CONVERTER
D943 TRANSFORMER (MAIN)
SYSTEM CONTROL
IC302 (3/3)
PVDD
I-PROTECT-F 27
45
I
53
SEG0
PROTECT-F
I
56
I SEG32
79
ND301
LIQUID
CRYSTAL
DISPLAY
PANEL
D
TUNER/AUDIO
SECTION
(Page 18)
83 COM3
I
I
86 COM0
25 I-KEY1
3
POWER
CONTROL
Q933
PH931
ISOLATION
D301,302
LCD BACK
LIGHT
VOLTAGE
DETECT
Q930
15 MAIN CLOCK
TH901 (EX66)
TH902 (EX88/EX99)
RECT
D981
4
VREF
K
3
VOLTAGE
DETECT
IC966 (EX88)
IC966 (EX99)
1 D
D967
D970
+19V REG (EX88)
+22V REG (EX99)
Q965
D972
6 BD
5 FB/OLP
1 OUT
RECT
D967
AEEUHYLDWLRQ
EA SDXGL AUDELD PRGHO
T901
DC-DC CONVERTER
TRANSFORMER
PVDD
1 D
RECT
D965
4
VREF
K
3
VDD 2
D940
VOLTAGE
DETECT
IC932
DC-DC
CONVERTER
IC930
+22V
LIMITER
Q930
3 VCC/OVP
D934
6 BD
PH930
ISOLATION
D303,305,307,
309,310
2 VDD
+12V REG
IC602
POWER
CONTROL
Q601,602
1
1 OUT
VDD 2
V2
10 O-VOL-LED
O-STBY-SW 42
+3.3V(C)
OUT 1
28 I-AC-CUT
RESET
Q310
EX66
STANDBY
CONTROL
Q308,309
+3.3V(A)
E+4V
4 VOUT
+9V REG
IC701 (EX66)
IC701 (EX88)
IC701 (EX99)
3
+9V
O-VBUS-ON 39
(Page 17)
D315
+13V
POWER
CONTROL
Q700,701
M+7V
1
VC
4 VOUT VIN 2
1
VBUS+5V
2 SW
VBUS OCP
DETECT
Q704
I-VBUS-OCP 40
19
V2
VIN 2
+3.3V(B)
POWER
CONTROL
Q702,703
CD SECTION
HCD-EX66/EX88/EX99
+4V REG
IC700 (EX66)
IC700 (EX88)
IC700 (EX99)
O-SUB-ON 38
I-RST
C
PVDD
VOLTAGE DETECT
IC603 (EX66)
IC603 (EX88)
IC603 (EX99)
RESET
IC307
+3.3V(A)
3
5 O-DIMMER
I-V2-MONI 34
LED
DRIVER
Q304
5 FB/OLP
O-MAIN-ON 37
+9V
+12V
DIMMER
CONTROL
Q302
DC-DC
CONVERTER
IC965 (EX88)
IC965 (EX99)
3 VCC/OVP
PH965
ISOLATION
V2
POWER
CONTROL
Q970
43 O-LCD-LED
+5.7V REG
Q301
RECT
D901 (EX88)
D902 (EX66/EX99)
7 OCP/BD
V2
VOLTAGE DETECT
IC604
LED
DRIVER
Q303
DC-DC
4 VCC CONVERTER
IC931 (EX88)
IC931 (EX99)
T903
DC-DC CONVERTER
TRANSFORMER (SUB)
13 SUB CLOCK
16 MAIN CLOCK
E+4V
POWER
ON/OFF
Q932
6 FB
D937
F931
X302
20MHz
D941
EX88/EX99
12 SUB CLOCK
X301
32.768kHz
PH930
ISOLATION
POWER
CONTROL
Q602,603 (EX88)
Q600,601 (EX99)
29 I-RMC
VOLTAGE
DETECT
IC932 (EX88)
IC932 (EX99)
POWER
CONTROL
Q934,935
4 VOUT VIN 2
VCONT
1
+12V
24 I-KEY2
REMOTE CONTROL
SIGNAL RECEIVER
IC301
4
VREF
K
3
+12V REG
IC602 (EX88)
IC602 (EX99)
26 I-KEY0
S301,303–309,
312–316
KEY MATRIX
1 D
OVER CURRENT
DETECT
Q600,601 (EX88)
Q602,603 (EX99)
19
5
SS
+7V REG
IC702 (EX66)
IC702 (EX88)
IC702 (EX99)
EX88/
EX99
IN 1
VBUS+5V REG
IC703 (EX66)
IC703 (EX88)
IC703 (EX99)
EX66
PVDD
L901,902 (EX88/EX99)
L903 (EX66)
L904 (EX66: EA MODEL)
F901
AC IN ~
HCD-EX66/EX88/EX99
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed in each block.)
For Printed Wiring Boards.
For Schematic Diagrams.
Note:
• X : Parts extracted from the component side.
•
: Pattern from the side which enables seeing.
(The other layers’ patterns are not indicated.)
Note:
• All capacitors are in μF unless otherwise noted. (p: pF) 50
WV or less are not indicated except for electrolytics and
tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
f : Internal component.
• 2 : Nonflammable resistor.
• C : Panel designation.
Caution:
Pattern face side:
(SIDE B)
Parts face side:
(SIDE A)
Parts on the pattern face side seen
from the pattern face are indicated.
Parts on the parts face side seen from
the parts face are indicated.
• Abbreviation
AR
: Argentina model
E2
E4
EA
MX
: Mexican model
• Waveforms
– BD76 Board –
1 IC101 2 (RFOUT)
0.6 to 1.5 Vp-p
Note: The components identified by mark 0 or dotted
line with mark 0 are critical for safety.
Replace only with part number specified.
3.3 Vp-p
1 V/DIV, 10 Psec/DIV
2 IC101 us (XOUT)
2 IC302 qh (Main Clock)
16.934 MHz
2.6 Vp-p
1 V/DIV, 20 nsec/DIV
20 MHz
2.9 Vp-p
3 IC901 7 (CF2)
– TUNER Board –
12 MHz
3.1 Vp-p
1 IC502 ql (X2)
32.768 kHz
200 mV/DIV, 5 Psec/DIV
TUNER board
LOADING board
REGULATOR board
(EX88/EX99)
EFX-MODULE board
AMP SMPS board
HCD-EX66/EX88/EX99
32.768 kHz
200 mV/DIV, 500 nsec/DIV
• Circuit Boards Location
PANEL board
1 IC302 qd (Sub Clock)
(CD play mode)
• A : B+ Line.
• B : B– Line.
• Voltages and waveforms are dc with respect to ground
under no-signal (detuned) conditions.
– BD76 Board –
no mark : CD PLAY
– Other Boards –
no mark : TUNER (FM/AM)
* : Impossible to measure
• Voltages are taken with VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production
tolerances.
• Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production
tolerances.
• Circled numbers refer to waveforms.
• Signal path.
F
: TUNER (FM)
f
: TUNER (AM)
J
: CD
E
: USB
q
: DVD/PC IN
• Abbreviation
AR
: Argentina model
E2
E4
EA
MX
: Mexican model
BD76 board
– PANEL Board –
20
20
0.6 Vp-p
HCD-EX66/EX88/EX99
PRINTED WIRING BOARD – CD Section –
2
1
• See page 20 for Circuit Boards Location.
3
4
5
•
: Uses unleaded solder.
6
7
8
9
10
BD76 BOARD (SIDE A)
A
12
13
14
BD76 BOARD (SIDE B)
R305
C303
R304
11
C304
+
B
28
22
1
7
30
–
M
21
15
8
14
IC301
C302
29
R301
R302
M401
(SPINDLE)
C301
CL203
R303
5-4.
SL301
S001
(LIMIT)
S001
SL303
CL202
SL304
CL204
C
+
SL302
CL401
R417
C133
CL116 CL121
CL118
M
M402
(SLED)
R416
R124
C416
C415
C208
E C B
11
(11)
CN201
R203
R911
CL213
IC901
37
36
CL908 CL909 CL907
G
21
21
R403
CL901
CL206
OPTICAL
PICK-UP
BLOCK
(DA11MMVGP)
9
1
8
CL906
CL904
21
2
1
C955
CL416
R953
R954
11
(11)
1-883-378-
R914
CL905 CL903
Q201
R955
CL421
R912
24
25
R922
CL420
R909
1
48
CL419
R908
C405
12
13
CL418
R923
C951
C908
R907
R910
16
R924
R951
R906
CL214
1
C907
R902
1-883-378-
CL119
C202
CL120
R903
R952
R905
CL107
R404
R117
C406
C204
C209
C206
R202
C417
R414
C111
C110
C207
C124
C953
C201
R129
R114
CL207
R201
R415
R113
CL212
C112
C401
CL211
20
CN401
C905
R406
2
CN901
FLASH
CL902
PROGRAMMING
PANEL
BOARD
CN303
(Page 24)
CL417
CL415
R116
CL117
HCD-EX66/EX88/EX99
R405
A
CL414
R407
C121
CL105 CL106
C407
F
R408
C126
SL201
R111
R409
41
40
C952
20
21
C901
CL104
C120
C119
R904
R112
CL405
R412
CL407
R120
R109
CL205
CL413
R118
CL406
C108
C107
X901
R413
C906
C106
CL412
CL109
R121
C113
C402
C118
R108
CL404
CL110
R122
IC101
CL403
CL111
R123
CL108
C105
C903
R901
R401
61
60
R107
C104
C902
80
C909
CL210
1
C904
R103
R106
CL402
CL409
R913
R104
–
CL408
CL411
CL112
CL102
R105
CL113
C125
CL208
CL209
R402
R411
CL115
C130
CL101
C123
C131
CL410
CL114
R126
C122
C127
R102
C128
X101
C132
C116
C102
C103
CP201
E
R101
C117
C129
D
C101
C418
CL201
HCD-EX66/EX88/EX99
5-5.
SCHEMATIC DIAGRAM – CD Section (1/2) –
1
2
• See page 20 for Waveforms. • See page 44 for IC Block Diagrams.
3
4
5
6
7
8
BD76 BOARD (1/2)
C116
100
16V
A
9
10
11
12
C132
0.1
C133
0.1
C130
0.1
C131
0.1
R106
0
1.7
1
M
R108
1k
C119
100 16V
CL103
R107
68k
CL117
3.3
0.8
C105
3
SP-
R109
1k
C107
0.01
1.7
0.1
3.3
CL104
SL+
C118
0.1
R111
22k
0.01
3.3
0
SL-
CL118
CL121
CL116
3.3
0
0
0
0
1.6
3.3
1.7
1.5
3.3
3.3
1.7
DVDD
PCMLRSY
PCMBCK
PCMREQ
PCMDATA
DVSS
DVDD15
DVDD
DOUT
CONT4
7 BIN
8 DIN
AD_LRCK(STREQ) 54
CL113
0
R124
10k
0
R123
10k
0
R122
10k
TEST0 53
IC101
9 SLCISET
10 RFMON
11 VREF
12 JITTC
RESB 47
DO 46
15 PCNCNT
16 TE
DI 45
CL 44
17 TEIN
18 LDD
19 LDS
20 AVSS
CE 43
DVSS 42
DVDD 41
3.2
3.2
1.7
8
9 10 11 12 13 14
3.2
3.2
1.7
1.7
R302
33k
IC301
FOCUS/TRACKING COIL DRIVE,
SPINDLE/SLED MOTOR DRIVE
OPOUT
29
GND
7
R301
5.6k
IC B/D
OPIN
RESETt
VO3-
VO3+
6
VO2-
IN2’
5
IN2
VO2+
GND
IN3
IN3’
VCC
7
GND
GND
VCC
4
0
MUTE
IN4’
REGOUT
3
7
REGB
BIAS
IN4
RESET
2
3.2
IN1
VO4+
21 20 19 18 17 16 15
VO1+
GND
30
VO1-
VO4-
C301
220
10V
1
3.2
IC301
BA5826HFP-E2
H
R303
12k
SPSP+
SL302
SL301
SL+
I
HCD-EX66/EX88/EX99
SL-
22
22
0.1
C112
CL108
R411
100
R118
100
3.3
R408
100
3.3
R407
100
0
R406
100
R409
3.3
3.3
C126
0.1
100
R120
10k
11
12
13
14
15
16
17
C113
0.1
18
3.3
1.6
0
3.3
0
0
3.3
CL120
68k
R116
0.022
C111
C121
0.1
C302
0.1
7
3.3
1.7
3.2
3.2
C303
0.1
28 27 26 25 24 23 22
S001
(LIMIT)
C120
0.1
C304
0.1
G
0.22
SL303
R304
10k
C110
R305
8.2k
9
10
3.3
R121
10k
CL119
3.3
1.1
1.8
CL106
R114
680
0
CL105
680
R113
1.7
1.7
1.7
1.7
3.3
C122
0.1
SL304
F
R117
10k
8
CL109
21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40
E
7
CL110
CONT2 50
INTB1 49
INTB0 48
6
CL111
CONT1 51
13 EIN
14 FIN
5
CL112
CONT0 52
IC101
LC786950T-US-H
CD-MP3 PROCESSOR
AVDD
4
1.7
1.6
C108
R112
0
M
M402
(SLED)
1.7
1.7
2
D
C106
3300p
0.1
CL114
VVSS3
1.7
AD_BCK(STCK) 55
VVDD3
0
AD_DATA(STDATA) 56
DVDD15
R105
5 AIN
6 CIN
DVSS
1.7
DVDD
1.7
0
R417
0
CL115
C2F(LRSY) 60
TEST1 57
STDATA(C2F)
0
R104
SL201
3
DEFECT(DATA) 58
STCK(FSEQ)
R103
CL201
SP+
1
2
FSEQ(DATACK) 59
STREQ(DEFECT)
CL202
C104
M401
(SPINDLE)
1.7
2
1
3 LPF
4 PHLPF
LIMIT-SW(CONT3)
0.1
1.6
CONT5(M-MUTE)
1
C103
CL102
4700p
1.7
C101
XVSS
2
F-
0.01
1 EFMIN
2 RFOUT
VVDD1
T+
CL203
C102
1.7
XOUT
3
R203
0
CL204
330 CL101
PCKIST
T-
CL205
R101
XIN
4
C208
1000p
PDOUT0
5
F+
1.6
XVDD
MD
C209
0.1
PDOUT1
6
100
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61
LRVDD
7
IC B/D
R102
10k
CL206
VVSS1
LD
VR
CL207
1.7
8
LCHO
9
GND
C418
100p
4
3.3
SPDO
10
F
3.3
Q201
2SA2119K
AUTOMATIC
POWER CONTROL
C117
0.047
1.7
C
CL208
R202
2.2
C207
100
16V
RCHO
11
CL214
CL209
C206
1
LRREF
B
R201
1
SLDO
12
CL210
1.7
A
CL211
SLCO
13
C127
0.1
R416
X101
16.934MHz
CL213
1
D
CL212
C204
14
1
15
E
TDO
C
VCC
C201
0.1
LRVSS
OPTICAL
PICK-UP
BLOCK
(DA11MMVGP)
16
C202
B
VREF
C129
100
16V
C128
1
R126
0
FDO
CN201
16P
R405
100
R404
100
CL107
20
21
22
C123
1
C124
100
16V
19
C407
47p
C406
47p
C125
0.1
1
BD76
BOARD
(2/2)
(Page 23)
HCD-EX66/EX88/EX99
5-6.
SCHEMATIC DIAGRAM – CD Section (2/2) –
1
2
• See page 20 for Waveforms. • See page 48 for IC Pin Function Descriptions of IC901.
3
4
5
6
7
8
9
10
11
BD76 BOARD (2/2)
1
A
2
3
4
B
C402
100 16V
CN401
21P
CL401
5
CL402
6
R402
7
BD76
BOARD
(1/2)
C
R413
8
1
(Page 22)
0
CL403
0
CL404
CL405
9
R412
10
0
CL406
CL407
11
CL408
12
CL409
13
CL410
14
CL411
15
CL412
16
CL413
17
CL414
CL415
CL416
D
CL417
R401
18
0
CL418
CL419
CL420
CL421
19
21 CD-M-GND
20 CD-VM7V
19 AVDD3.3V
18 CD/USB-Rch
17 AU-GND
16 CD/USB-Lch
15 AGND
14 CD-M-MUTE
13 CD-RST
12 CD-DO
A
11 CD-DI
10 CD-CL
9
CD-CE
8
USB-SLEEP
7
USB-RXD
6
5
USB-TXD
4
DVDD3.3V
3
2
D+
1
D-GND
PANEL
BOARD
(3/3)
CN303
(Page 27)
USB-RST
D-
100
100
100
R415
22
R129
21
R414
20
C401
100 16V
E
C417
47p
C416
47p
C415
47p
R901
100
R914
100k
CL901
R403
100
0
0
0
0
0
DBGP2
SDAT
BCLK
P20
LRCK
P00 21
41
UFILT
42
AFILT
43
P32
44
URX1
IC901
VSS2 20
VDD2 19
IC901
LC87F1JJ2AU-SQFP-H
USB CONTROL
UTX1
P17 16
46
P70
P16 15
47
P71
48
P72
3
R909
100
CL909
R910
100k
R902
100
3.3
C909
0.1
0
R908
100
SCK1 14
9 10 11 12
X901
12MHz
C902
22p
3.3
3.3
R904
0
R905
100
R907
100
R906
100
C906
100p
C904
0.01
C903
27p
100p
8
C905
7
100p
6
C908
100p
SO1
5
SCK0
4
SI0
SO0
3
3.3
2
3.3
VDD1
SI1 13
1
3.3
C901
0.1
CL908
0
MCLKI 17
45
CL906
CL907
MCLKO 18
R903
1M
H
0
R911
100
CL905
R912
100k
C907
P21
P22
P23
P24
P25
VSS3
CF2
100
100
40
R924
R923
R922
100
3.3
G
P01 22
1.9
0.8
DBGP0 23
VDD3
CF1
3
C405
100p
UHD+
39
1.5
2.7
38
VSS1
C955 R955
0
2.2
DBGP1 24
XT2
5p
5p
C952
C951
15k
15k
R952
R951
C953
2.2
1.8
P26
P27
0
3.3
UHD-
XT1
33
CL903
CL904
37
RES
R953
0
P73
33
CL902
36 35 34 33 32 31 30 29 28 27 26 25
3.3
F
R954
0
0
R913
100
I
HCD-EX66/EX88/EX99
23
23
CN901
9P
1
GND
2
GND
3
VDD
4
VDD
5
DBGP2
6
GND
7
DBGP1
8
DBGP0
9
TRESET
(
FLASH
PROGRAMMING
)
HCD-EX66/EX88/EX99
PRINTED WIRING BOARD – PANEL Section –
3
4
5
•
6
7
8
9
(Page 29)
B
(Page 31)
(Page 34)
(Page 39)
C
D
E
(EX66)
S309
TUNING –
lm
JR304
JR301
JW374
2
1
JW372
JL357 JL355 JL353 JL352
JL358
21 20
R389
C420
C360
R419 R417
JW334
PHONES
R484
R488
C444
C441
JW333
C370
C366
R414
R412
R416
JW329
J302
D326
JW388
C359
C436
Q325
C1 B2 E2
E1 B1 C2
C430
JR302
C362
R420
C361
C462
C433
JR307
R491
R470
C425
R390
C412
D325
C410
JR308
22
23
R452
C363
C364
JW387
R407
R406
R479
JW335
BCE
Q316
BCE
Q315
R427
R428
16
17
C390
C393
IC306
1
C374
R478
R474
R401
R402
R494
R498
R403
R404
6
5
4
7
C378
JW407
JW391
R480
R495
R475
Q321
R499
R489
JW331
(USB)
ET301
R497
1 4
R486
R493
C440
1
R434
R388
JW330
JW332
CN304
R432
JW389
C445
C437
Q319
R492
R496
R487
BCE
R481
C438
8 5
IC308
R476
R482
R485
C382
C381
R473
C442
C428
R477
R471
C426
C431
R472
BCE
R444
R445
CN304
C427
12
S315
R358
S316
S314
C411
JL351
CN306 CN307
(23P) (21P)
JL359
R458
BCE
ECB
Q311 Q317
R459
C398
C397
C409
R422
C367
JR303
R418
-2
R
1-883-783-
S316
24
C371
C372
C375
C376
C373
JW404
R426
R423
R425
A001
R355
(Page 21)
32
C405
JW369
JW406
JW405
JW401
C399
1 4
8 5
R438
D319
R431
IC305
D324
C389
JW417
JW394
JW393
JW337
C385
TUNING+
ML
24
C392
C391
D305
S315
ENTER
R357
JL314
21 20
S313
REC TO USB
JW397
A
R460
C449
R441
R443
R314
R317
R315
R437
S312
S312
C396
C395
C388
C365
R356
JW340
R451
BCE
C416
JW371
C423
BCE
Q302
D309
S304
3
R305
R311
R301
S313
JL318
x
C406
JL362
R413
JW306
JW373
C421
ECB
Q314
Q313
R306
BCE
1
C402
DVD/PC IN
C459
EX88/EX99
C401
J301
JL360
JL361
EX66
-1
L
C458
JL341
C448
C434
R442
R440
C377
JL322
JW359
JL328
R439
R436
R435
JL332
JL316
1
C422
R323
R318
ECB
Q304
Q312
D310
R337
R342
BCE
JW414
JW385
JW384
JW383
JW386
JW376
JW382
JW378
JW377
JW380
CN303
JL320
FLASH
PROGRAMMING
CD
MECHANISM
DECK
JW395
JW396
JL331
2
R373
1
CN302
7
6
CN301
EX88/
EX99
D305
DSGX
BD76 BOARD
CN401
HCD-EX66/EX88/EX99
JW408
C457
R456
R447
EX66
JL326
JL317
5
R464
JL356
JW328
JL315
JL319
R453
R455
JW327
JW409
JL330
2
R449
C452
C454
JR310
R448
1
JL333
JL313
JL303
S305
JW375
1
JW339
JW390
4
JW360
JL324
JL312
R465
JL354
R469
R446
R308
JW364
R405
R383
R368
C329 R366
R365
1 JL311
2
JL302
6
IC304
JL327
JL310
JL301
JL304
R468
R304
D303,307,309
(VOLUME RING)
5
R399
JL329
R374
JW353
JL306 JL307
R454
C344
C345
JW365
R300
C331R384
JL309
JW363
JL321
JW362
JW358
JW357
JW356
D311
JW355
JR306
R381
ECB
Q305
C342
JW336
JL305
JW352
C419
R378
C323
JL308
R380
H
JW411
JW347
JW361
R372
JW322
ECB
IC303
R336
D303
JL325
C328
C413
C435
R338
R325
JW314
R377
R463
R461
S304
(VOLUME)
JW410
JL323
JW354
R462
C418
JR309
R332
R345
JW318
JW313
R379
R382
R307
JL348
JL350
EX99
JW351
R326
JW320
R322
JW321
JW319
C456
JW323
9
Z
C356
JW338
R324
JW324
S308
JW381
JW367
Q301
R430
Q309
JW366
Q310
BCE
R363
D307
R352
JW317
D301
Q303
C308
R309
R310
R351
JL343
R319
C301
R353
R362
R328
R329
R330
R331
JW403
C333
1
0
10
81 0
8
D302
ECB
JW349
R204
5
1
4
3
R433 C384
IC307
R424
C319
X302
C320
JW348
R360
JW400
D301,302
(LCD BACK LIGHT)
I
R320
R321
JL345
JL347
JL349
R466
JW304
C343
51
JW413
JW350
JW343
R333
R334
D312
JW345
JR305
R371
JW344
JW342
R340
R346
R354
D313
R376
R367
C322
JR311
R364
CN306 23P (EX99)
CN307 21P (EX66/EX88)
JL344 JL346
JL342
R467
JW303
R429
R370
S305
JW368
C451
JW311
JW309
C337
JW316
R398
Q308
R386
X301
EQ
D310
JW399
R343
R344
37
JL337
R409
JW346
C379
50
ND301
LIQUID CRYSTAL DISPLAY PANEL
C318
OPTIONS
R359
R361
D315
JW307
C380
D318
IC302
JW402
F
G
C408
EX88/EX99
R375
EX66/EX88 R369
C325
30 1
3
R392
E
JW310
JL334
JW308
JW312 R385
JR313
R394
R393
JW325
R397
R396
ECB
R421
1
D316
C336
C335
S306
C450
6
R400
JW326
JW398
JL339
7
JL335
C353
JW315
JL336
1
2
S308
FUNCTION
JL340
JW379
JW392
JW415
R411
R410
D
R387 JW341
R327
C309
1
3
2
R339
IC301
S306
R347
JW412
R341
JL338
CN305
JW370
R335
C
R350
JW416
NX
R348
B
R349
(EX99)
S309
S303
S303
*/1
S307
S301
S301
(EX88)
Q324
PANEL BOARD
11
AMP SMPS BOARD
CN600
TUNER BOARD
CN501
A
10
ECB
2
1
C439
5-7.
(12)
HCD-EX66/EX88/EX99
SCHEMATIC DIAGRAM – PANEL Section (1/3) –
3
4
5
6
8
7
9
C456
0.1
R396
R400
4.7k
10k
0.7
O-LCD-LED
3.2
3.2
1.8
R392
100
I-RDSI
0
0
R397
4.7k
I-VBUS-OCP
O-VBUS-ON
D316
RB501V-40TE-17
R398
100
O-MAIN-ON
3.2
R393
100
I-PROTECT-S
3.2
R394
100
I-V2-MONI
3.2
O-HP-MUTE
3.2
O-AMP-RST
3.1
0
O-SW-MUTE
2.9
O-FR-RELAY
R387
10k
R411
10k
5
1
2
3
2
I-SIGNAL
R431
68k
R437
100k
C377
2.2
50V
C389
2.2
50V
R421
10k
D319
MC2840-T112-1
D324
MC2840-T112-1
C353
1000p
R425
1k
C367
1
R410
10k
O-SUB-ON
3.2
IC305
IC305
NJM4558V-TE2
VACS/SIGNAL LEVEL CONTROL
4.5
R422
56k
R423
10k
4.5
4.4
C365
22
16V
R426
1k
0
I-PROTECT-F
I-AC-CUT
2.8
3.1
3.2
I-KEY0
3.2
I-KEY1
I-KEY2
3.2
3.2
I-VACS
0
I-LED-LEVEL
0
0.1
I-SUFFIX
2.2
I-MODEL
3.2
0.7
3.3
1.3
1.6
0.4
3.2
I-CD-OP/CL
9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30
VDD1
8
1.7
7
VSS1
6
O-FR-RELAY 31
SEG0
NC
1.6
C408
0.1
VCC
GND
8
I-SIGNAL-LEVEL
Main Clock(20MHz)
Main Clock(20MHz)
Sub Clock(32.768kHz)
Sub Clock(32.768kHz)
5
I-RST
4
O-VOL-LED
I2C-TU-CLK
3
0
2
3.2
1
I2C-TU-DATA
100 O-CD-M-MUTE
O-SW-MUTE 32
SEG1
1.5
Q309
ISA1602AM1-T111-1EF
STANDBY CONTROL
3.2
CD
D318
DA2J10100L
9
7
I-CD-DO
I-V2-MONI 34
O-AMP-RST 33
1.5
3.2
GND
4.5
6
99
O-CD-DI
2
I-PROTECT-S 35
SEG2
R409
10k
2.5
VDD
4.5
5
O-CD-CL
O-HP-MUTE 36
30 O-FAN-LOW-SPEED
1.5
Q308
2SC4154TP-1EF
STANDBY CONTROL
0
OUT
C384
0.1
1
DGBP2
98
29 I-RMC(SIRCS)
2
SEG3
C380
0.1
2
97
1
O-CD-RST
1
SEG4
1.5
3.2
3
DGBP1
SEG5
1.5
I-VACS
SEG6
SEG7
DGBP0
96
1.5
3.2
C379
0.1
4
SEG6
1.5
1.5
1.5
3.2
VDD2
SEG8
VSS2
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
SEG30
95
4.4
R435
1k
1
3
R438
100k
R439
470
C391
47
16V
C399
0.1
R436
1k
O-FAN-LOW-SPEED
I-RMC
I-AC-CUT
I-PROTECT-F
I-KEY0
I-KEY1
RB501V-40TE-17
D313
I-VACS
6
I-KEY2
RB501V-40TE-17
I-SIGNAL
I-HP/CD-SW
D312
R386
R367
100
0
0.1
22p X301
32.768kHz
C322
100k
R364
100
R363
18p
100
5
7
EX88/
EX99
1000p
1000p
220p
C335
C336
C337
10k
10k
R376
R385
R375
*
*2
10k
1
1000p
C325
R369
0.1
C318
8
14
13
12
11
10
9
X302
20MHz
2
PANEL BOARD (3/3)
(Page 27)
25
25
*1
R369
1k (EX66)
10k (EX88)
*2
R375
1k (EA)
2.2k (E4)
10k (MX)
22k (E2,E51,AR)
PANEL
BOARD
(2/3)
(Page 26)
C385
1
4
G
HCD-EX66/EX88/EX99
SEG7
0.1
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
1.5
O-MAIN-ON 37
R371
SEG32
O-VBUS-ON 39
I-USB-RXD
C320
SEG31
I-RDSI 41
94
C319
SEG30
0
I-VBUS-OCP 40
I-RST
SEG29
O-CD-M-MUTE
0
IC302
LC87F7DJ2CVU-QIP-H
SYSTEM CONTROL
O-USB-TXD
R362
SEG28
1.3
O-STBY-SW 42
93
O-VOL-LED
SEG27
100
IC302
O-SUB-ON 38
I2C-TU-CLK
SEG26
R351
O-CD-CL
I-CD-DO
O-USB-SLEEP
4.7k
SEG25
0.2
92
R361
SEG24
0.2
100
O-CD-ON
100
SEG23
0.2
100
R331
VDD3
91
R360
SEG22
100
R330
DGBP2
90
I2C-TU-DATA
SEG21
R329
DGBP1
100k
VSS3
4.7k
SEG20
DGBP0
100k
R326
89
SEG0 45
R359
SEG19
100k
R325
O-LCD-LED 43
I2C-FUNC-CLK
SEG18
R324
NC 44
O-CD-M+
I2C-FUNC-DATA
SEG17
0
O-CD-M-
88
4.7k
SEG16
100
COM0
87
4.7k
SEG15
R328
86
R353
SEG14
I-USB-RXD
SEG1 46
R352
SEG13
0
SEG2 47
COM1
3.2
SEG12
O-USB-TXD
COM2
85
O-CD-RST
SEG11
0
3.2
ND301
LIQUID CRYSTAL DISPLAY PANEL
SEG10
O-CD-ON
O-USB-SLEEP
84
O-DIMMER
7
SEG9
3.2
8
SEG8
0.1
9
SEG7
C308
SEG3 48
I2C-FUNC-CLK
5
0
COM3
3.2
0
O-CD-M+
83
I2C-FUNC-DATA
4
O-CD-M-
SEG4 49
3
1.5
SEG5 50
LCD V1
3
1.5
COM0
LCD V2
R430
47k
R429
47k
Q310
2SC4154TP-1EF
RESET
82
O-DIMMER
COM1
37 36 35 34 33 32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10
SEG6
1.5
1.5
C333
0
O-USB-RST
1.5
SEG3
SEG5
H
3.3
IC307
PST3629NR
RESET
R433
4.7k
R204
47k
C356
470
4V
81
0.1
COM2
SEG2
SEG4
1
1.5
6
SEG0
2
COM3
COM3
SEG1
F
SEG8
SEG9
SEG10
SEG11
SEG12
SEG13
SEG14
SEG15
SEG16
SEG17
SEG18
SEG19
SEG20
SEG21
SEG22
SEG23
SEG24
SEG25
SEG26
SEG27
SEG28
SEG29
SEG30
SEG32
COM2
R344
4.7k
R345
4.7k
SEG31
R332
4.7k
COM1
E
R424
10k
I-RST
O-CD-CE
JL307
IC307
I-AC-CUT
80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
0
JL306
1.3
7
R343
1k
O-USB-RST
VCC
DGBP2
O-CD-CE
6
JL305
3
5
VCC
JL304
SEG32
DGBP2
DGBP1
LCD V3
4
DGBP0
JL303
1.3
DGND
JL302
O-CD-DI
3
1
2
2
1
DGBP1
I-RST
3
RESET
DGBP0
JL301
15
IC B/D
D315
MC2836-T112-1
COM0
D
14
13
1
CN301
7P
C
12
11
PANEL BOARD (1/3)
A
B ( FLASH )
PROGRAMMING
10
4
2
1
• See page 20 for Waveforms. • See page 44 for IC Block Diagrams. • See page 49 for IC Pin Function Descriptions of IC302.
SEG31
5-8.
HCD-EX66/EX88/EX99
5-9.
SCHEMATIC DIAGRAM – PANEL Section (2/3) –
1
2
3
• See page 44 for IC Block Diagrams.
4
5
6
7
8
9
10
11
12
13
14
15
PANEL BOARD (2/3)
CN305
7P
1
A
C450
10
16V
C451
4700p
2
JR303
0
JR304
0
I-RDSI
JL334
I2C-TU-CLK
JL335
I2C-TU-DATA
JL336
JL337
JL338
JL339
JL340
JW306
JL344
B
JL346
JL347
JL348
JL349
JL350
JL351
3
0
JR301
1
(Page 25)
JR302
0
C
I-VBUS-OCP
JL352
O-VBUS-ON
JL353
O-SUB-ON
JL354
O-MAIN-ON
JL355
I-PROTECT-F
JL356
I-PROTECT-S
JL357
I-V2-MONI
JL358
O-FAN-LOW-SPEED
JL343
O-AMP-RST
JL359
EX66
C448
0.15
C449
0.15
R389
*3
R390
*3
D
O-HP-MUTE
I-HP/CD-SW
O-SW-MUTE
EX99
Q311
ISA1602AM1-T111-1EF
6
R452
2.2k
0
8.5
7
*1
8
F
*4
C363,364
4700p (EX99)
3900p (EX66/EX88)
C452
100
10V
R427,428
27k (EX99)
33k (EX88)
39k (EX66)
9
C454
1000p
0
R463
10k
R453
1k
R449
22k
9
R464
100k
Q316
2SC4154TP-1EF
0
C413
10
16V
Q317
2SC4154TP-1EF
R458
22k
C426
2.2
50V
C427
2.2
50V
R480
4.7k
R475
22k
R406
15k
R407
15k
C363
*1
R427
*4
4.4
C364
*1
R428
*4
4.4
4.3
16
R412
47k
4.3
R414
47k
C366
1
C370
1
4.5
4.5
H
R416
17
I
C459
1000p
IC306
BD3491FS-SE2
C371
100k
4.3
1
R417
100k
C372
1
4.3
R401
2.2k
R418
10k
C359
470p
C375
1
4.3
R402
2.2k
R419
10k
C360
470p
C376
1
4.3
R403
1k
R413
6.8k
C361
2200p
C373
1
4.3
R404
1k
R420
6.8k
C362
2200p
C374
1
4.3
PANEL
BOARD
(3/3)
3
(Page 27)
INPUT FUNCTION SELECTOR
IC B/D
J
15
14
13
12
11
10
9
8
7
6
5
4
IC306
18
16
3
2
1
TRE-R
BASSB-L
TRE-L
BASSA-L
VOL-L
BASSA-R
VOL-R
BASSB-R
SEL-R
OUT-L
SEL-L
SB-L
PC-IN-L
SURR
PC-IN-R
SB-R
CD/USB-L
OUT-R
CD/USB-R
VCC
TUNER-L
SCLK
TUNER-R
SDATA
TC-L
GND
TC-R
FIL
NC
NC
NC
NC
17
18
19
20
21
22
23
24
25
26
27
28
4.3
C395
0.047
4.5
C396
0.047
4.5
C397
0.047
C398
0.047
C401
*2
4.3
4.5
4.5
4.3
4.5
C405
C406
4.5
*2
*2
*2
R446
0
3.2
3.2
R444
220
I2C-FUNC-CLK
R445
220
I2C-FUNC-DATA
C393
3300p
4.4
C388
100
6.3V
31
32
C392
1000p
JW337
*2
*5
R451
1k
R447
47k
C409
100
10V
153799342
21
22
23
R461
10k
R466
1k
9
R476
4.7k
R486
8.3
R468
1k
XX
VBUS-GND
9
VBUS-OCP
R459
2.2k
17 AMP-RST
18 L-OUT
19 A-GND
20 R-OUT
21 A-GND
22 SW-OUT
23 FR-RELAY
CN307
21P
(EX66/EX88)
M+7V
M-GND
5
E+4V
0.7
6
E-GND
R499
10k
7
VBUS+5V
8
VBUS-GND
9
VBUS-OCP
(Page 32)
C
D
R469
1k
R470
100k
15 V2-MONI
16 FAN LOW SPEED
18 L-OUT
19 A-GND
C442
2.2
50V
C438
220
10V
2.2k
C440
0.1
R493
2.2k
47k
R487
20 R-OUT
21 A-GND
R496
4.7k
47k
IC308
4
R473
10k
4.2
R477
33k
4.2
8.3
C437
0.1
C433
100
10V
R474
100
R478
100
5
GND
2
7
8
1
VCC
C445
10
16V
4
3
6
4
4.2
R388
10k
4.2
R497
33k
C444
100
10V
R484
1k
R491
1k
0.7
0.7
0
R494
100
R498
100
0
100k
6800p
R488
C441
100k
6800p
D326
MC2840-T112-1
E
J302
PHONES
RED
J301
2P
DVD/PC IN
ET301
(CHASSIS)
WHT
K
26
-2
R
26
-1
L
AMP SMPS
BOARD
(1/2)
CN600
(EX66)
AMP SMPS
BOARD
(1/2)
CN600
(EX88)
(Page 35)
17 AMP-RST
C430
0.1
C410 C462
0.1 1000p
AMP SMPS
BOARD
(1/2)
CN600
(EX99)
(Page 40)
16 FAN LOW SPEED
VCC-GND
R495
10k
E
15 V2-MONI
4
1k
R479
C436
C420
100p
VBUS+5V
8
IC308
NJM3414AV(TE2)
HEADPHONE AMP
C428
10
16V
C401,402,405,406
0.039 (EX66/EX99)
0.033 (EX88)
C411
100p
E-GND
7
C439
10
16V
Q325
IMX9T110
MUTE
R441,443
18k (EX99)
22k (EX66/EX88)
E+4V
6
VCC+9V
R492
100k
Q319
2SC3052EF-T1-LEF
+8.3V REG
8.9
R482
R462
6.8k
C425
0.01
24
HCD-EX66/EX88/EX99
C431
2.2
50V
C423
47
10V
C412
2.2
50V
D325
MC2840-T112-1
Mount Mecha A001
2.9
R448
47k
19
20
R456
100k
M-GND
5
3
2.5
R485
100k
R467
100k
Q315
2SC4154TP-1EF
4.3
2.4
C416
1
R455
1k
R443
*5
M+7V
4
11 SUB-ON
2.4
R441
*5
9
29
30
C402
C390
0.022
C419
0.27
VCC-GND
3
14 PROTECT-S
2.9
Q313
2SC4154TP-1EF
9
1.7
VCC+9V
2
13 PROTECT-F
C418
0.27
R442
22k
1
12 MAIN-ON
R460
10k
R454
100k
R440
22k
L-CH
TUNER
B BOARD
CN501
(Page 28)
10 VBUS-ON
R481
Q314
2SC4154TP-1EF
9
2.3
9V
7
2
8.6
C421
0.33
6
1
Q324
2SC4154TP-1EF
MUTE CONTROL
0
R489
10k
3.2
R389,390
100 (EA)
0
(EXCEPT EA)
R472
4.7k
R471
4.7k
R465
1k
Q312-315
SUBWOOFER
AMP
*3
3.1
C422
0.018
G
0.18
R-CH
14 PROTECT-S
JL362
0
1.6
2.2
Q312
2SC4154TP-1EF
0.18
C434
EX88/
EX99
Q321
ISA1602AM1-T111-1EF
MUTE CONTROL
5
E
C435
A-GND
5
13 PROTECT-F
JL342
Q311,316,317
SUBWOOFER
MUTE
I2C-DATA
4
12 MAIN-ON
JL341
4
I2C-CLK
3
11 SUB-ON
JL361
O-FR-RELAY
RDSI
2
10 VBUS-ON
JL360
C457
1000p
C458
1000p
1
CN306
23P
(EX99)
JL345
PANEL
BOARD
(1/3)
16
HCD-EX66/EX88/EX99
5-10. SCHEMATIC DIAGRAM – PANEL Section (3/3) –
1
3
2
4
6
5
7
8
10
9
11
(Page 25)
PANEL BOARD (1/3)
14
13
12
11
9
10
2
A
PANEL BOARD (3/3)
JW303
IC301
0
D307
1L434XA22E0DDT01
4.3
E
R314
100
D305
1L434XA22E0DD701
R305
100
R315
33
1
CD
MECHANISM
DECK
M+
5
M-
4
OPEN SW
3
CLOSE SW
2
DGND
1
4.7k
4.7k
R339
1k
R327
470
9
4
0
RNF
3
8
7
6
5
OUT1
R357
2.2k
DSGX
S314
3
2
R350
4.7k
S308
OPTIONS
S309
TUNING–
R358
4.7k
OUT2
S315
VREF
2
EQ
REC TO USB
0
1
R349
2.2k
S307
R356
2.2k
4.9
4.7
R379
22k
O-CD-M+
O-CD-MR381
4.7k
Q305
2SC4154TP-1EF
MOTOR CONTROL
R382
33k
C331
0.1
C328
10
16V
C329
22
16V
R384
33k
ENTER
S316
17
18
R300
33k
TUNING+
IC303
LOADING MOTOR DRIVE
C309
0.1
EQ
R366
4.7k
JL308
I-RMC
D303,307,309
(VOLUME RING)
R377
R380
16
D310
1L434XA22E0DD701
DSGX
CN302
5P
F
D309
1L434XA22E0DDT01
R317
68
IC301
PNA4823M02S0
REMOTE CONTROL
SIGNAL RECEIVER
Q304
2SC3052EF-T1-LEF
LED DRIVER
R304
100
FUNCTION
22k
D303
1L434XA22E0DDT01
R311
33
R348
2.2k
S304
ROTARY ENCODER
(VOLUME)
C301
0.1
7
R370
Q302
2SC4154TP-1EF
DIMMER CONTROL
7
D311
DA2J10100L
R301
100
S313
0
0
VCC
R338
10k
R323
4.7k
D
S306
R355
1k
VM
R337
10k
GND
Q301
2SC3052EF-T1-LEF
+5.7V REG
RIN
GND
FIN
R347
1k
R342
8.2k
R321
220
1.4
IC B/D
10k
R320
10k
2
6.1
R336
15k
S312
/
S303
OUT
R319
100
S305
VCC
6.1
5.7
R318
1k
R308
100
S301
R341
4.7k
2.8
9
R306
33k
R307
470
IC303
BA6956AN
0
R335
10k
O-DIMMER
C
R354
1k
10k
O-VOL-LED
D301,302
(LCD BACK LIGHT)
R346
1k
R368
O-LCD-LED
R334
I-KEY2
I-KEY0
R322
10k
0.7
R310
68
D302
1L0341Y23E0CA602-II
R340
1k
R333
10k
3.1
R309
68
B
Q303
2SC4154TP-1EF
LED DRIVER
0.5
I-KEY1
JW304
D301
1L0341Y23E0CA602-II
R365
4.7k
JL309
JL310
C323
0.1
JL311
3
JL312
R374
22k
R372
22k
R373
22k
(Page 26)
R378
10k
R383
10k
CN303
21P
I
9
USB-SLEEP
8
USB-RXD
7
USB-TXD
6
USB-RST
5
DVDD3.3V
4
D+
3
D-
2
D-GND
1
JL324
IC B/D
O-CD-CE
JL326
O-USB-SLEEP
JL327
I-USB-RXD
JL328
O-USB-TXD
JL329
O-USB-RST
22
GND
IC304
O-CD-CL
JL325
6
IC304
MM1923DTRE
+3.3V REG
CONT
CD-CE
O-CD-DI
VIN
CD-CL 10
(Page 23)
I-CD-DO
JL323
5
4
3
2
1
R399
22k
3.1
CD-DI 11
O-CD-RST
JL322
GND
A
JL321
VO
CD-DO 12
O-CD-M-MUTE
9
CD-RST 13
BD76
BOARD
(2/2)
CN401
JL320
R405
10k
JL330
JL331
C345
100
10V
JL332
JL333
1
H
21
JL319
C343
CD-M-MUTE 14
JL318
CS
AGND 15
JL317
3.3
CD/USB-Lch 16
JL316
0.6
AU-GND 17
O-CD-ON
JL315
1
CD/USB-Rch 18
20
JL314
0.1
AVDD3.3V 19
JL313
C344
CD-VM7V 20
C342
CD-M-GND 21
19
I-HP/CD-SW
G
1
5
R432
2.2
R434
2.2
(USB)
7
4
J
3
2
CN304
4P
6
C382
220
10V
C381
1
C378
0.1
23
24
HCD-EX66/EX88/EX99
PANEL
BOARD
(2/3)
27
27
HCD-EX66/EX88/EX99
5-11. SCHEMATIC DIAGRAM – TUNER Section –
1
• See page 20 for Waveforms. • See page 45 for IC Block Diagrams.
2
3
4
5
6
TUNER BOARD
JL508
CN502
3P
JL509
A
D503
MC2837
D502
MC2837
D501
MC2837
JL510
R507
0
BPF
G
FL501
O
1
3
B
2
I
R505
0
IC B/D
L501
AM ANT
6
R508
100
4
IC502
AM/FM DET, OSC,
MIX,PLL,IF AMP
D
(Page 26)
B
2
1
16
17
GND
3.3
VDDRF
VDD
15
1
X2
14
CP2
0.4
13
1
X1
0
CP1
FRF1
IISD
GNDRF
LOUT
ARF1
0
ARF2
0
IIC/RDSI
3.3
LA
ROUT
1
DA
C502
GND
1
VDD
C501
12
2
18
19
20
3.3
9V
L-CH
100
11
3
0.4
3
R503
R504
10k
4
0.2
4
R-CH
JL503
R506
10k
5
0.8
A-GND
100
6
1.7
5
100
R502
7
1.7
6
R501
JL502
8
3.2
I2C-CLK
I2C-DATA
JL501
9
3.3
7
10
CK
3.2
PANEL
BOARD
(2/3)
CN305
RDSI
IC502
RS5B800-0002E2
CN501
7P
0
C506
0.047
C
JL504
JL505
X501
32.768kHz
JL506
JL507
C513
0.01
R509
100k
0.5%
C503
3300p
C504
0.01
C505
1
L502
10uH
L503
1uH
F
HCD-EX66/EX88/EX99
28
28
5
IC501
+3.3V REG
3
9
C511
100
10V
4
2
1
9
C514
0.033
IC501
S-815A33AMC-I2STFU
3.3
E
C516
0.47
7
C512
0.47
1
AM
2
AM
3
FM
ANTENNA
FM/AM
HCD-EX66/EX88/EX99
5-12. PRINTED WIRING BOARD – TUNER Section –
5-13. PRINTED WIRING BOARD – MODULE Section –
5
6
7
TUNER BOARD
3
7
D819
EX66
D820
D818
CL807
R810
C803
CL808
D816
C804
C809
CL809
D817
1
64
C810
CL802
R809
D815
C811
C813
JL813
CL805
R811
IC800
CL817
C816 (EX66/EX88)
C828 (EX99)
JL814
R806
EX88/EX99
C800
R808
C807
D
R800
JL815
17
16
48
49
D809 (EX66)
D805 (EX88/EX99)
12
(12)
R814 R813
EX66/
EX99
EX88 JL816
32
33
C812
CN502
3
C
JL510
1-883-784-
ET801
JL812
D811 (EX66)
D807 (EX88/EX99)
D501
1
D502
CN502
ANTENNA
FM/AM
R815
EX66:EA MODEL
D810 (EX66)
D806 (EX88/EX99)
R507
JW502
6
ET800
EX66:EA MODEL
D808 (EX66)
D804 (EX88/EX99)
C511
JW503
JR502
C513
FL501
C826 (EX99)
C817 (EX66/EX88)
JL508
JL509
D503
L502
R508
JW504
JR510
20
C504
C506
JW507
X501
JW501
1
IC502
R509
C505
L503
C502
11
C503
C501
10
R503
B
R505
R504
C514
D
R502
R506
JL506
JR501
C516
5
4
C512
3
1
IC501
C
JL507
JW505
JL504
CN501
(Page 24)
L501
R501
JL505
7
6
PANEL
BOARD
CN305
2
B
1
B
5
EFX-MODULE BOARD (SIDE A)
A
JL501
JL502
JL503
4
C829 (EX99)
A
2
1
C827 (EX99)
4
C825
(EX66/EX88)
3
•
C824
(EX66/EX88)
2
1
•
1-883-488-
E
AMP SMPS BOARD
CN604
F
EFX-MODULE BOARD (SIDE B)
(Page 39)
(EX99)
1
JL817
M
2
JL818
(Page 34)
R817
5
JL821
6
R823
JL822
2
R825
(EX88)
AMP SMPS BOARD
CN603
(EX88)
CN801
I
JL806
(Page 39)
JL807
(EX99)
L
JL809
JL811
5
JL827
(Page 39)
(Page 34)
JL808
R802
JL828
6
N
29
R820
JL810
JL826
(Page 34)
(EX99)
29
C814
CN803
K
HCD-EX66/EX88/EX99
JL802
JL800
8
R819
11
(EX66)
JL805
2
JL825
F
5
JL824
(Page 31)
I
R824
JL804
6
H
(EX66)
1
C820
JL803
C821
1
H
(Page 31)
JL801
7
G
AMP SMPS BOARD
CN605
12
(EX66)
R818
R822
JL820
C808
R812
C815
(Page 31)
JL823
CN802
J
CL812
JL819
(EX88)
G
11
(11)
1-883-488-
11
(11)
HCD-EX66/EX88/EX99
5-14. SCHEMATIC DIAGRAM – MODULE Section –
1
3
2
4
5
6
8
7
9
11
10
12
13
EFX-MODULE BOARD
C812
0.1
C809
330p
C815
0.1
C810
0.1
C816
2.2
E
(EX99)
0.01
4700p (EX66/EX88)
EX66
C828
2.2
100V
EX99
D808
SS110R3
*1 C800
CL817
D804
*2
R812
0
3.3
3.3k 0.5% (EX99)
8.2k 0.5% (EX66/EX88)
3.3
*4 R810
47k 0.5% (EX99)
56k 0.5% (EX66/EX88)
R818
*3 R808
R817
CL812
JL813
JL811
CL805
R800
100
R802
100
JL812
OSC_IO/SD
GND_C
GND_C
/OTW1
GND_D
JL816
EX66/EX88
50
50
EX99
D809
SS110R3
D805
*2
40 41 42 43 44 45 46 47 48
50
50
GND_A 49
PVDD_A 50
PVDD_A 51
*
*
OUT_A 52
OUT_A 53
2.2
BST_A 54
12
12
GVDD_B 56
GVDD_A 55
NC 59
GND 58
GND 57
NC 60
NC 61
1
2
3
4
OUT_C
*
*
EX66/EX88
C827
2.2
100V
C824
2.2
C820
0.1
50
50
JL822
C821
0.1
JL823
JL824
JL825
*
*
JL826
EX66
JL827
C829
2.2
100V
EX99
C825
2.2
(EX66)
IC B/D
(EX88)
IC B/D
(EX99)
EX66/EX88
P6SMBJ54A-5
(EX99)
P6SMBJ40A-5
(EX88)
30
30
3.3
3.3
EX66/EX88
C817
2.2
EX66
D811
SS110R3
EX99
C826
2.2
100V
D807
*2
0.1
C813
R819
HCD-EX66/EX88/EX99
R820
0.1
0
C811
0
R815
EX99
R813
R814
0
E
E
ET801
(CHASSIS)
EX66:EA MODEL
C814
0.1
JL828
G
CN802
6P
(EX66)
(Page 32)
1
OUT-A
2
PVDD-A
3
GND
4
OUT-B
5
PVDD-B
6
GND
1
GND
2
PVDD-C
3
OUT-C
4
GND
5
PVDD-D
6
OUT-D
CN803
6P
*2 D804-807
IC B/D
JL818
JL820
JL821
1.9
1.9
JL817
JL819
D806
*2
3.2
OUT_C
OSC_IO+
33 34 35 36 37 38 39
JL815
FREQ_ADJ
31 PVDD_D
32 GND_D
JL810
JL814
30 PVDD_D
JL809
R811
10k
0.5%
PVDD_C
50
JL808
R809
10k
0.5%
INPUT_D
BST_C
PVDD_C
28 OUT_D
29 OUT_D
JL807
1
INPUT_C
*
JL806
VREG
BST_B
50
1.9
*
1.9
EX88/EX99
PVDD_B
IC800
TAS5630BPHDR (EX99)
TAS5613APHDR (EX88)
TAS5611APHDR (EX66)
POWER AMP
27 BST_D
EX66
PVDD_B
IC800
2.2
100
AGND
26 GVDD_D
/CLIP 12
100
R825
3.3
GND
24 GND
25 GVDD_C
/OTW2 11
R824
JL805
0.1
VI_CM
12
9
JL804
C804
OUT_B
12
/SD
/OTW1 10
100
INPUT_B
23 GND
8
R823
OUT_B
22 M3
7
JL803
GND_B
INPUT_A
21 M2
D
/RESET
CLK_SEL
100
JL802
C_STARTUP
3.3
(Page 40)
6
R822
1.9
GND_B
3.3
(EX99)
INPUT-D
JL801
1000p
/RESET
19 READY
20 M1
L
5
1.9
VDD 64
PSU_REF 63
12
(Page 35)
4
3.2
18 /CLIP
(EX88)
INPUT-B
INPUT-C
CL809
EX66
GND_A
OC_ADJ
17 /OTW2
I
3
CL802
(Page 32)
2
GND
3.2
3.2
AMP SMPS
BOARD
(1/2)
CN605
(EX66)
INPUT-A
C803
D820
MC2840-T112-1
F
1
JL800
D819
MC2840-T112-1
C
GVDD
1.2
CL808
1.9
D816
MC2838-T112-1
CN801
12P
*1
CL807
ET800
(CHASSIS)
EX66:EA MODEL
5
C800
R810
*4
6
R808
*3
7
220p
8
R806 C807
100
16 15 14 13 12 11 10 9
D818
MC2840-T112-1
D817
MC2840-T112-1
D815
MC2838-T112-1
B
NC 62
C808
0.1
EX88/EX99
1.9
EX66/EX88
EX66
D810
SS110R3
A
J
(EX88)
(Page 35)
M
(EX99)
AMP SMPS
BOARD
(1/2)
CN604
(Page 40)
H
(EX66)
(Page 32)
K
(EX88)
(Page 35)
N
(EX99)
(Page 40)
AMP SMPS
BOARD
(1/2)
CN603
HCD-EX66/EX88/EX99
VDR901
R649
C701
C706
JW624
JW636
JW658
ECB
JW634
CL630
C703
5
1
C700
Q704
ECB
R722
C714
1
6
5
IC703
C967
R996
JW652
L700
CL965
D967
C710
JW908
ET965
L903
CL904
JL975
T901
C977
JW917
JW902
JW915
JW920
JW950
JW914
ET931
JL973
JW656
4
3
5
1
IC603
3 4
IC932
C971
R938
Q930
3
4
ET903
R670
JW951
PH930
C E
CL936
R945
D941
CL937
CL931
C934
C932
CL907
R971
D930
R936
C911
–
CL906
R965
R673
JW919
7
R987
R935
C931
JW903
D931
1
JW928
C930
CL935
C941
6 CL930
CL933
IC930
C916
C914
R934
R933
C935
C939
R944
C912
+
D902
2
~
CL905
I
R937
D932
CL932
CL934
D938
~
TH902
C907
JW953
B C E
C937
R939
JW952
H
2 1
JW925
D933
C677
R977
R978
JS902
EXCEPT
EA MODEL
D934
D940
5
R976
JS904
JS905
JW912
R947
C678
R674
R672
C679
1
C980
C676
R671
JW926
IC604
L904
(EA)
EXCEPT
EA MODEL
JW922
JW921
L967
R975
G
JL974
C903
JW904
JW657
JW923
C902
CL908
12
A930
1-883-496-
AMP SMPS BOARD (HCD-EX66)
HCD-EX66/EX88/EX99
31
31
PANEL
BOARD
CN307
(EX66)
(Page 24)
6
IC700
CL634
JW659
R718
C716
R719 JW627
ECB
R990
BCE
C709
R972
C
JW605
D965
A931
C600
R747
R744
R712
R702
R701
Q700
JW633
JW625
CL627
R707
R710
R708
R720
F931
F
JW907
R700
JW629
R709
R728
R723
R724
R725
R726
R727
R721
C969
JL902
C905
JW637
Q701
D700
JL901
R995
R901
R989
JL903
CL901
CL902
JW901
JW900
C976
ECB
L966
Q703 Q702
1
F901
E
3
B C E
R703
R704
R705
R706
R711
Q970
R991
CN901
C702
JW643
JW654
ET901
1
C705
JW602 R713
JL970
ET600
C708
R717
C713
R716
R745
CL625
CL636 CL631 CL629
2
1
R992
CL638
JW631
CL640
JL969
JW621
JW609
CL639
CL628
JW933
AC IN ~
1
C707
CL610 CL623 JW639
CL641
JW930
3
5
CL632
IC701
A701
2
JW655
CL626
JW614
JW931
JW653
JR603
C624
CL637
JW642
R605
R607 R609
C607
5 8
JW601 R602
C603
4
CL624
CL635
JW626
JW615
R729
C717
JW638
IC702
A700
JW648
ECB
Q706
BCE
ECB
R731
JW650
CL633
R743
Q712
JW607
R699
JW622
R613
R612
JW649
C606
JS600
JS601
C648
R600 JW651
JW619
JW632
4 1
5 8
IC601
R611
IC600 R608
C608
C665
R601
C604
C611
R663
JW932
CL621
CL618
CL622
CL649
R617
R604
CL619 CL617
C609
R618
D704
R730
JR607
C622
R606
JW613 R603
C666
JR605
R627
CL650
CL620
CN605
7
8
11
12
R615
C668
JR602
CL614
CL616
C667
5
CL651
JR601
JR600
CL615
1
2
CL613
JW646
6
JW628
R616
CL652
6
1
JW618
5
R634
C620
R619
R630
CN604
JW644
6
5
C626
L605
Q602
R620
B C E
R621
R629
R628
R625
Q601
2
BCE
1
L609
C656
JW623
JW600
JW630
C638
C647
C655
R638
C664
D
C628
CL648
C613
C615
JW603
CL611
CN603
L607
C640
CL647
R
C645
C653
L604
3
D702
R733
JW645
D701
R732
R734
R753
R752
A702
EA MODEL
C601
Q707
R641
R642
C639
JW640
JW620
R633
C646
1
CL612
JW610
JW608
2
R637 C654
L606
IC602
JW616
C627
C662
R635 C649
C663
I0PEDANCE8SE 4
R632
JW635
C643
CL646
SPEAKERS
JW604
JW612
L603
C644
C651
C650
L
R631
C641
L608
CL645
TB600
JW611
C625
R643
C652
L602
C637
R640
E C B
C719
JW641
11
Q708
C720
R715
F
Q711
R746
G
10
JW606
H
Q705
JW617 D703
(Page 29)
EFX-MODULE
BOARD
CN801
(EX66)
9
21
20
(Page 29)
EFX-MODULE
BOARD
CN802
(EX66)
8
CN600
(Page 29)
D601
BCE
Q709
C658
C657
C642
FB601
3
CL644 CL643 FB600
CN700
1
R639
R645
C721
7
EFX-MODULE
BOARD
CN803
(EX66)
RED+
BLK–
R647
R646
R644
R636
BLK
R739
R741
C661
C
RED
R648
BCE
C660
BCE
BCE
C659
BCE
Q604
Q605 Q606 Q607
B
R738
R740
R737
6
4 1
FAN701
DC FAN
A
5
C718
4
•
ECB
3
JW647
2
1
ECB
5-15. PRINTED WIRING BOARD – AMP SMPS Section (HCD-EX66) –
(12)
HCD-EX66/EX88/EX99
5-16. SCHEMATIC DIAGRAM – AMP SMPS Section (1/2) (HCD-EX66) –
4
5
7
6
8
9
AMP SMPS BOARD (1/2) (HCD-EX66)
6
4.7k
4.7k
14.4
1
3
C706
10
50V
C705
0.1
R710
10k
IN
SW
GND
ADJ
SS
4
5
5.2
3
R722
1k
R720
1k
0.5%
C709
0.1
R711
100k
C710
470
35V
R718
330
0.5%
R719
470
0.5%
IC702
SI-3010KFEK
IC B/D
R728
10k
R721
3.3k
0.5%
L700
47uH
C714
680
10V
R723
3.3
R724
3.3
R725
3.3
R726
3.3
R727
3.3
CN700
3P
IC702
C708
47
25V
C703
47
10V
C713
100
10V
C707
0.1
R746
22k
3.2
Q711
RT1N141C-TP-1
DC DETECT
Q705
2SC4154TP-1EF
DC DETECT R730
100
0
R729
100k
Q712
2SC4154TP-1EF
0
C717
2.2
50V
Q706
2SC4154TP-1EF
0
0
R629 10k
R628 10k
R625 10k
R621 10k
G
2
11.7
3
IC604 IC B/D
L602
10uH
ET600
(CHASSIS)
4.7
VDD
GND
CD
NC
C679
1000p
3.2
4
OUT
VDD
GND
CD
NC
5
OUT
2.2
1
22k
C601
1000p
R674
E
V2_13.4-17V
3.2
R673
47k
2
EA MODEL
3
CL641
R670
CL640
1.9
C627
470
35V
C677
1000p
C624
2200
35V
V2_GND
R602
22k
6
6.2
5.9
5
C607
47p
R604
56k
R605
22k
7
2
5
C645
2200p
C648
2200p
R634
3.3
0
11.3
C660
47
0
11.3
11.3
0
Q605
R644 ISA1602AM1-T111-1EF
220k
Q607
R647 ISA1602AM1-T111-1EF
220k
R643
220k
R646
220k
R645
220k
R648
220k
1k
C651
0.022
L608
0.6uH
L607
0.6uH
C646
2200p
C647
2200p
0
11.3
11.3
Q606
ISA1602AM1-T111-1EF
11.3
R636
3.3
C643
2200p
C644
2200p
6
7
R612
4.7k
R613
4.7k
FAN+
R741
3.3
TB600
4P
4
CL646
3
C652
0.022
C653
0.022
C654
0.022
CL645
C661
1000p
C662
1000p
C663
1000p
CL647
2
CL648
1
-
L
R
SPEAKERS
IMPEDANCEUSE 4ȍ
GND1
R637
3.3
L609
0.6uH
+
+
C664
1000p
C655
0.022
C656
0.022
R638
3.3
(Page 33)
2
AMP SMPS
BOARD
(2/2)
(EX66)
CN603
6P
C613
100
16V
6
OUT-D
5
PVDD-D
4
GND
3
2
OUT-C
1
GND
H
PVDD-C
EFX-MODULE
BOARD
CN803
(EX66)
(Page 30)
CN604
6P
1
1
6.1
6
GND
5
PVDD-B
4
OUT-B
3
2
GND
1
OUT-A
G
PVDD-A
EFX-MODULE
BOARD
CN802
(EX66)
(Page 30)
CN605
12P
CL613
C615
0.1
CL612
CL614
8
CL615
CL616
CL617
C667
CL618
1
CL619
CL620
CL652
C668
CL621
1
CL622
J
HCD-EX66/EX88/EX99
L606
0.6uH
Q604
ISA1602AM1-T111-1EF
11.3
11.3
R640
22k
R739
3.3
R627
10k
CL651
R609
2.2k
C650
0.022
FAN-
3
R740
3.3
R738
3.3
C721
4.7
50V
CL611
IC601
NJM4558V-TE2
PRE AMP
8
R607
56k
C666
C649
0.022
C642
2200p
R633
3.3
C638
1
C719
0.01
C659
47
C641
2200p
2
FAN701
DC FAN
+
-
R737
220k
C720
0.01
C657
1
50V
R639
22k
FAN+
Q709
2SC4154TP-1EF
FAN MOTOR DETECT
0.2
1
VCC
C609
0.1
3
6.1
6.1
4
IC601
CL650
C665
R663
22k
0.5%
11.7
VCC
IC600
NJM4558V-TE2
PRE AMP
C606
0.15
1
6.1
2
6.1
3
R616
4.7k
R615
4.7k
R608
56k
VSS
4
IC600
C604
1000p
CL649
R611
2.2k
C608
47p
R601
22k
5.9
C603
0.15
R606
22k
R618
2.2k
0.5%
VSS
R603
56k
H
I
C628
470
35V
R617
2.2k
0.5%
C611
100
10V
C640
1
L605
10uH
PVDD_25V
PVDD_GND
L604
10uH
C639
1
D601
MC2840-T112-1
R635
3.3
R632
3.3
L603
10uH
IC603
PST3629NR
VOLTAGE DETECT
47k
IC604
PST3629NR
VOLTAGE DETECT
R672
47k
C637
1
C626
470
35V
IC603 IC B/D
0.01
CL639
18k
CL638
R641
47k
C658
10
50V
R631
3.3
C625
470
35V
C622
47
16V
C620
100
35V
R619
100k
O
4
CL637
6.1
(EX66)
(Page 33)
1
I
0.1
JS601
SUB_ON
1
25
JS600
C600
0.01
AMP SMPS
BOARD
(2/2)
IC602
KIA7812API-U/PF
+12V REG
24.3
CL636
A-GND 1
G
R642
100k
IC602
CL635
R671
R-OUT 2
25
CL634
C676
A-GND 3
R630
10k
R600
1k
CL633
5
L-OUT 4
CL632
4
AMP-RST 5
CL631
6.1
F
PROTECT-F 9
PROTECT-S 8
V2-MONI 7
FAN LOW SPEED 6
Q601
2SC4154TP-1EF
POWER CONTROL
0.7
CL630
11.7
(EX66)
(Page 26)
CL629
1
MAIN-ON 10
CL628
6.2
C
R620
1k
CL627
6.1
PANEL
BOARD
(2/3)
CN307
VBUS-OCP 13
VBUS-ON 12
SUB-ON 11
CL626
2
VBUS+5V 15
VBUS-GND 14
CL625
3
E+4V 17
E-GND 16
0.01
M-GND 18
E
25.1
Q602
KTA1273-Y-AT
POWER CONTROL
CL624
5.2
Q604-607
OVERLOAD DETECT
CL610
CL623
C678
VCC+9V 21
1k
C718
0.1
R699
10k
VCC-GND 20
M+7V 19
R753
1k
Q707
2SC4154TP-1EF
0.3
0.8
R743
47k
CL644
1
FB601
3.2
R734
22k
0.8
R731
100
R752
R732
1k
3.2
*
R745
22k
R715
10k
0.5%
Q706,707,712
FAN MOTOR CONTROL
CL643
4.5
Q708
KTC3203Y-AT
FAN MOTOR REG
D702
D701
DZ2J082M0L DZ2J047M0L
R707
15k
0.5%
R708
15k
0.5%
R709
10k
0.5%
R716 R717
27k
33k
0.5% 0.5%
R733
5
14.4
D704
DZ2J047M0L
ADJ
4
FB600
D703
MC2838-T112-1
VOUT
3
1.2
GND
2
7
VADJ
1
R712
2.2k
1.2
4
IC700
SI-3010KM-TLS
+4V REG
VIN
VOUT
5
VC
GND
4
2.9
VIN
3
D
CN600
21P
C716
0.1
5.2
3.6
0
15
R747
22k
IC B/D
IC700
GND
VCONT
2
14.5
1
14.5
C702
0.1
2
14
13
+7V REG
6
C
G
R713
Q702
470k
2SC4154TP-1EF
POWER CONTROL
0.7
R744
22k
9
O
2
C701
10
50V
Q700
2SC4154TP-1EF
POWER CONTROL
R701
100k
I
14.5
4.7k
4.7k
IC701
KIA7809API-U/PF
+9V REG
0.1
R702
10k 0.7
Q703
2SC4154TP-1EF
POWER CONTROL
IC701
R706
R705
R704
R703
C700
470
25V
B
R649
0
13.7
1
25.1
Q701
KTA1273-Y-AT
POWER CONTROL
R700
1k
IC703
SI-8008TM-TLS
VBUS +5V REG
14.4
D700
RK36LF-A4
14.5
12
Q704
ISA1602AM1-T111-1EF
5.2
0
GND
IC B/D
IC703
A
11
10
3.6
3
0.9
2
1
32
32
1
GVDD
2
INPUT-A
3
GND
4
INPUT-B
5
INPUT-C
6
INPUT-D
7
/RESET
8
CLK_SEL
9 /SD
10 /OTW1
11 /OTW2
12 /CLIP
F
EFX-MODULE
BOARD
CN801
(EX66)
(Page 30)
HCD-EX66/EX88/EX99
1
3
2
4
5
6
7
8
9
10
12
11
13
14
VDR901
JL903
R901
1.5M
1/2W
C905
0.22
250V
4
3
1
2
4
3
1
2
L903
18mH
C907
*1
L904
18mH
C911
0.01
250V
IC B/D
R934
0.33 2W
GND
VCC/OVP
S/GND
D
7
6
5
4
3
2
1
R933
0.33 2W
CL934
CL933
CL932
CL931
CL930
C939
3300p
400V
R944
ET903
100k
(CHASSIS) 3W
C931
100p
6
10
5
11
15
15
13.8
2
C977
0.1
1
C967
2200
35V
E
16
C937
47
50V
D930
DZ2J300M0L
F
C932
4700p
22.7
D941
UDZSUSTE-1730B
CL937
3
PH930
PS2561AL1-1-V-W
VOLTAGE DETECT
1
2
R965
1k
3
4
2
1
33
33
R995
2.2k
1W
Q970
2SC4154TP-1EF
POWER CONTROL
0.7
R990
10k
R977
33k
0.5%
R978
4.7k
0.5%
G
HCD-EX66/EX88/EX99
IC932
MM1431CURE
IC932
4
0.1
R976
10k
0.5%
R971
220k
CL936
JW922
JL970
JW930
JL969
R975
0
C971
0.01
R945
100
JL974
C980
10
50V
V2_13.4-17V
V2_GND
PVDD_GND
JW933
R996
2.2k
1W
R987
1k
R939
100k
JW921
C976
22
35V
L966
2.2uH
R972
0
Q930
+22V LIMITER
R936
47k
0.5%
C934
4.7
ET965
(CHASSIS)
15
R937
4.7k
JL973
CL965
14
D940
D1NL20U-TR2
D932
DZ2J220M0L
L967
10uH
C969
2200
25V
13
R947
4.7
F931
T2.5A
250V
12
D934
DZ2J160M0L
Q930
2SC5053T100Q
D931
DZ2J360M0L
D967
RK49LF-T1
4
R938
27k
0.5%
D933
DZ2J180M0L
C941
1
100V
9
7
E
D938
SARS03
C935
560p
1kV
D
E
8
CL908
CL935
R935
2.2k
0.5%
T901
DC-DC CONVERTER TRANSFORMER
*
15
ET901
(CHASSIS)
IC930
STR-Y6766
DC-DC CONVERTER
FB/OLP
E
BD
IC930
0.2
(Page 32)
CL902
GND1
C916
470p
250V
C930
0.1
CL907
0.9
(EX66)
2
C907
0.22 250V (EA)
0.33 250V (EXCEPT EA)
NC
C
AMP SMPS
BOARD
(1/2)
*1
JS902
C914
330
450V
~
JS905
EXCEPT
EA MODEL
CL901
C912
0.01
250V
~
2.4
B
EA MODEL
JL902
JL901
NC
3
D902
D3SB60F3
RECT
TH902
JS904
K
NEUTRAL
EXCEPT
EA MODEL
VREF
1
C903
470p
250V
A
AC IN ~
LIVE
C902
470p
250V
F901
T5AH
250V
CN901
2P
ET931
(CHASSIS)
E
CL904
D965
FMX-22SL
A
R992
2.2k
1W
R989
2.2k
JW931
PVDD_25V
JW932
R991
2.2k
1W
JL975
JW923
1
AMP SMPS
BOARD
(1/2)
(EX66)
(Page 32)
SUB_ON
HCD-EX66/EX88/EX99
7
8
9
(Page 29)
(Page 29)
(Page 29)
EFX-MODULE
BOARD
CN803
(EX88)
EFX-MODULE
BOARD
CN802
(EX88)
EFX-MODULE
BOARD
CN801
(EX88)
REGULATOR
BOARD
CN700
(EX88)
K
J
I
O
Q608
6
R651
R699
JW619
CL629
CL633
CL631
CL630
CL632
CL646
CL644
JW632
JR603
R603
JR607
R616
C605
C604
JW605
C625
CL601
R673
CL647
CL600
C677
JW923
JW922
D981
R980
R988
JW924
PH930
C E
C982
JW905
CL974
R998
IC965
1
7
C970
A932
D984
C968
CL968
JW916
R992
D972
R971
R970
CL966
B C E
D968
C972
R972
CL967
JW903
D967
6
CL972
Q965
JW919
JW917
C969
D975
R938
2
CL970
D937
C966
C967
CL969
CL908
C971
CL965
C975
R968
CL907
1 2
R979
D970 CL971
R969
JW928
R965
JW927
R975
R974
D939
C933
R935
JW907
C934
D930
JW920
R966
D932
C911
C932
R937
6
C935
IC931
~
BCE
Q930
R933
C939
C914
7
C930
C912
D901
D940
2
JW910
R978
JW908
C938
D931
JW915
C937
1
–
C909
D938
R941
R936
JW918
R944
C931
R930
JW909
~
TH902
C907
ET902
R942
E C B
+
R943
H
R931
CL975
3
IC966
CL973
R973
R939
JW926
Q932
CL906
JW904
D941 R934
R981
CL976 4
PH965
C E
C936
R945
JS902
D934
R984
R985
T903
R932
JW902
D935
CL905
JW906
L902
JW935
L969
JW925
CL931
ET931
C903
JW901
R670
JW921
JW934
R946
T901
CL930
R986
C977
1 2
IC932
PH931
C E
C986
C983
D969
R977
R947
JL601
R671
R987
4 3
3
C676
JS908
R958
R960 R956
1
JL974
C610
R610
R612
R617
JW914
D944
R949
ET930
ECB
JL600
JL603
R959
ECB
4
IC603
Q600
C947
Q933
C902
I
C950
JW913
ECB
ECB
JW932
R950
D943
CL904
G
C989
Q934
Q935
Q601
JL977
C946
L901
5
BCE
JL933
R957
R961
JL901
R951
F
JW912
JL902
C905
JW933
D985
JW929
VDR901
R901
R954
JW911
CL902
C943
C944
JL903
CL901
F901
E
JL932
JW623
JL973
CL602
JR604
CL650
R967
12
1-883-494-
HCD-EX66/EX88/EX99
34
34
PANEL
BOARD
CN307
(EX88)
(Page 24)
CL649
R672
JW930
L930
D
CL645
JW607
CL648
R620
1
R600
R601
R607
R613
21
20
R663
R621
1 4
IC600 C608
CN600
R618
8 5
R609
R619
JW633
R604
JR608
IC601
R674
R602
JW931
3
ET600
JW627
JW616
AC IN ~
CN901
CL643
JW604
JW612
1 4
C607
C612
JW622
R606
R608
8 5
JR606
C667
C666
CL651
R611
R614
CL653
CL652
CL619
R615
C613
C614
C668
JW625
C669
CL654
JL602
ET901
C600
JW608
JW618
6
JW620
CL642
JW600
BCE
JW614
CL634
CL635
CL636
CL637
CL638
CL639
CL640
CL641
C624
R624
1
IC602
CL620 CL618
CL623
5
R623
R628
5
1
CL628
JW617
JW629
6
CL617
R625
CL616
8
JW602
JW611
JW626
JR602
1
2
CL615
CN605
7
2
C629
16
A600
R675
CL612
CL614
5
C628
C641
L605
C639
R632
C648
C665
R636
C649
CL627
CN601
ECB
CL613
JW615
6
R630
R631
L607
L609
C656
C657
R626
R627
1
2
CN604
C638
C627
JW603
Q602
JW634
JW630
JW601
L604
CL626
D
JW624
CN603
R
C647
I0PEDANCE8SE 4
C646
C663
C651
R633
C650
R635
C655
C664
C654
TB600
C644
L606
CL625
SPEAKERS
R629
C645
CL624
L
C642
L603
C640
JW631
C
JW606
C643
C626
R642
R641
R637
R643
R638
R644
R646
C652
C653
L608
R634
C662
C619
JW635
JR605 JR601
JR600
L602
C658
R645
ECB
CL621
D601
11
C661
CL622
C659
12
BCE
5
C660
BCE
1
BCE
R639
R640
JW613
B
BCE
11
(Page 37)
Q603
Q604 Q605 Q606 Q607
A601
10
R622
C620
A
6
R989
5
2
4
C609
3
•
JW609
2
1
1
(12)
HCD-EX66/EX88/EX99
1
3
2
4
5
6
7
8
9
12
11
10
13
14
8
M+7V
7
GND
6
VBUS+5V
5
GND
4
9V
3
GND
2
V2
1
CL635
CL637
IC602
CL638
IC602
SI-3010KM-TLS
+12V REG
CL639
CL640
1
2
3
4
5
CL641
CL642
CL643
R623
470k
CN600
21P
R624
22k
VCC+9V 21
C
6
IC B/D
CL636
R626
100k
0.5%
R627
10k
0.5%
11.9
VCC-GND 20
M-GND 18
Q608
2SC4154TP-1EF
FAN SPEED CONTROL
0
E+4V 17
E-GND 16
Q602
RT1N141M-TP-1
POWER CONTROL
0
R699
10k
M+7V 19
Q603
2SC4154TP-1EF
POWER CONTROL
0
0
R651
47k
VBUS+5V 15
C624
47
16V
C619
100
16V
2.8
Q604-607
OVERLOAD DETECT
R639
47k
R640
100k
R628
10k
0.5%
C659
10
50V
VBUS-GND 14
D601
MC2840-T112-1
GND
CL634
VADJ
(EX88)
(Page 38)
9
GND
O
E+4V
CL633
VOUT
B
REGULATOR
BOARD
CN700
GND 10
CL632
GND
SUB_ON 11
CL631
1.1
VBUS_ON 12
CL630
VIN
VBUS_OCP 13
CL629
12
DC or FAN DET 14
CL628
VCONT
DC_DET 16
FAN_DET_CTRL 15
13.3
A
11.9
CN601
16P
Q604
ISA1602AM1-T111-1EF
16.4
C658
1
50V
VBUS-OCP 13
VBUS-ON 12
7
6
AMP-RST
5
L-OUT
4
A-GND
3
R-OUT
2
A-GND
1
MAIN_ON
V2_13.4V
V2_GND
AMP SMPS
BOARD
(2/2)
CL647
CL649
IC B/D
CL650
CL600
JL600
JL601
R617
2.2k
IC603
PST3629NR
VOLTAGE DETECT
R670
47k
C600
0.01
R671
18k
3.4
3.7
C676
0.01
1 OUT
CD
5
NC
4
1.8
2.8
2 VDD
3 GND
C677
1000p
0
Q601
ISA1602AM1-T111-1EF
OVER CURRENT DETECT
C610
0.22
50V
C628
470
50V
C625
2200
50V
C604
0.18
R673
1.5k
C612
100
10V
R603
47k
R613
2.2k
C608
47p
2
IC600
R604
47k
4
C609
0.1
3
2
IC601
5
C620
1000p
R622
2.2k
0.5%
C629
470
50V
C613
100
16V
C666
R611
2.2k
C652
0.022
L608
0.6uH
C660
47
R642
220k
R641
220k
6
7
C654
0.022
C647
2200p
C655
0.022
R631
3.3
C639
1
63V
L609
0.6uH
C662
1000p
Q605
ISA1602AM1-T111-1EF
R643
220k
16.4
C661
47
0
R644
220k
R645
220k
16.4
0
Q607
ISA1602AM1-T111-1EF
R646
220k
CL624
TB600
4P
4
CL625
3
CL626
2
CL627
1
C663
1000p
C664
1000p
CL652
C667
C656
0.022
C649
2200p
C657
0.022
R636
3.3
C614
0.1
CL612
CL614
CL613
CL615
CL616
CL617
CL654
C669
1
CL618
CL619
CL620
CL622
CL623
I
35
35
SPEAKERS
,03('$1&(86(ȍ
R
2
AMP SMPS
BOARD
(2/2)
(Page 36)
CN603
6P
1
1
-
L
(EX88)
C648
2200p
1
C668
+
GND1
1
8
+
C665
1000p
R635
3.3
CL621
HCD-EX66/EX88/EX99
16.4
16.4
0
C653
0.022
C646
2200p
R632
3.3
R614
4.7k
R615
4.7k
16.4
6
OUT-D
5
PVDD-D
4
GND
3
OUT-C
2
PVDD-C
1
GND
K
EFX-MODULE
BOARD
CN803
(EX88)
(Page 30)
CN604
6P
CL653
R608
47k
C645
2200p
C651
0.022
R634
3.3
C644
2200p
R638
22k
R625
10k
IC601
NJM4558V-TE2
PRE AMP
8
12
7
6.3
6
C607
47p
R602
15k
R606
15k
6
7.2
5
R675
1.5k
1
VCC
IC600
NJM4558V-TE2
PRE AMP
R674
1.5k
6.3
7.2
7.2
3
VSS
4
R618
4.7k
R619
4.7k
R609
47k
G
C605
0.18
R663
22k
0.5%
CL651
R601
15k
C641
1
63V
L605
10uH
R621
2.2k
0.5%
L606
0.6uH
R637
22k
0
L607
0.6uH
36.2
JL602
R607
15k
C640
1
63V
L604
10uH
36.3
Q600
2SC4154TP-1EF
OVER CURRENT DETECT
R612
22k
0
R610
100k
L603
10uH
R620
2.2k
JL603
R672
1.5k
H
C643
2200p
C650
0.022
R630
3.3
R616
0.05 5W
IC603
ET600
(CHASSIS)
PVDD_36V
C627
470
50V
CL648
E
PVDD_GND
C638
1
63V
R633
3.3
C642
2200p
CL646
1
F
L602
10uH
CL645
(EX88)
(Page 36)
R629
3.3
16.4
6.3
V2-MONI
FAN LOW SPEED
CL644
6.3
8
VCC
9
CL602
12
E
PROTECT-F
PROTECT-S
C626
470
50V
1k
7.1
(Page 26)
R600
6.3
(EX88)
CL601
VSS
SUB-ON 11
MAIN-ON 10
6.3
D
6.3
D
PANEL
BOARD
(2/3)
CN307
Q606
ISA1602AM1-T111-1EF
16.4
6
GND
5
PVDD-B
4
OUT-B
3
GND
2
PVDD-A
1
OUT-A
J
EFX-MODULE
BOARD
CN802
(EX88)
(Page 30)
CN605
12P
1
GVDD
2
INPUT-A
3
GND
4
INPUT-B
5
INPUT-C
6
INPUT-D
7
/RESET
8
CLK_SEL
9
/SD
10 /OTW1
11
/OTW2
12 /CLIP
I
EFX-MODULE
BOARD
CN801
(EX88)
(Page 30)
HCD-EX66/EX88/EX99
1
2
3
4
5
6
7
8
9
11
10
12
13
CL904
ET931
(CHASSIS)
E
A
L901
JL902
VDR901
JL903
1
C912
0.01
250V
L902
4
3
2
1
~
3
C907
0.33
250V
2
JS902
~
C909
1000p
250V
T901
DC-DC CONVERTER
TRANSFORMER (MAIN)
C914
330
450V
C911
0.01
250V
CL901
CL906
GND1
E
E
(EX88)
D940
SARS03
C931
1000p
1.5kV
*
S
4
Q932
2SA1364-T111-1DE
POWER ON/OFF
C932
1
100V
C937
47
100V
D941
D1NL20U-TR2
18.4
18.3
R945
22
5
14
4
15
L930
2.2uH
C944
1000
50V
C943
1000
50V
JL932
2
17
1
18
JW930
C950
22
50V
R954
0
D944
DZ2J180M0L
C947
0.1
R950
1k
R958
3.3k
0.5%
R956
22k
PVDD_36V
JW931
JL933
JW933
CL930
R957
4.7k
0.5%
CL931
PVDD_GND
JW932
E
R959
22k
0.5%
ET930
(CHASSIS)
D985
MC2838-T112-1
R930
0.22
2W
R942
10k
R938
3.3k
R933
100
0.5%
PH930
PS2561AL1-1-V-W
4
3
R932
220
R934
8.2k
D931
DA2J10100L
R931
0.22
2W
R936
1.5k
Q930
2SC4154TP-1EF
C933
220p
F
D934
DZ2J150M0L
Q930
R935
10 VOLTAGE DETECT
D937
0.7
DZ2J06200L
0
C936
470p
R939
2.2k
R973
2k
R974
1.8k
R975
1.8k
11.6
1
2
R946
1k
R949
6.8k
PH931
PS2561AL1-1-V-W
4
D938
DA2J10100L
R937
1k
D935
DA2J10100L
0.9
0.3
R941
10k
C989
22
50V
R977
5.6k
3
4
K
5
1.2
E
R960
2.2k
0.5%
IC932
VOLTAGE DETECT
2
1
1
3
2
R947
3.3k
1
Q933
RT1N441M-TP-1
R961
1k
2.8
JL977
JW921
16.5
(Page 35)
MAIN_ON
0.1
Q934
2SC4154TP-1EF
D939
DA2J10100L
C938
4700p
NC
19.3
0.3
1
19.4
19.1
CL969
CL966
18.8
19.3
R966
0.82 1W
CL965
2
3
C967
150p
2kV
CL968
R971
15k
0.5%
CL970
C972
220p
R972
1k
0.5%
C975
470p
500V
D970
D1NL20U-TR2
D975
EG01C LF-F7
R969
4.7k
D968
DZ2J220M0L
C968
1
R998
100k
1W
D972
DZ2J220M0L
C971
22
100V
6
12
5
11
4
R970
100k
10
C986
2700
16V
D981
RK49LF-T1
R978
4.7
2
8
1
7
R992
100
C969
4.7
C970
4700p
R984
220
PH965
PS2561AL1-1-V-W
4
1
CL973
CL972
3
2
CL974
VOLTAGE DETECT
36
C977
0.047
R986
4.7k
0.5%
CL976
R979
1k
IC966
36
R985
4.7k
0.5%
CL975
CL971
I
R988
0
R980
1k
R981
10k
0.5%
R967
47k
0.5%
L969
10uH
9
10.9
BD
*
CL967
Q965
+19V REG
Q965
2SC5053T100Q
D984
UDZSUSTE-1730B
FB/OLP
C966
0.1
4
GND
5
VCC/OVP
6
S/GND
7
D
T903
DC-DC CONVERTER
TRANSFORMER (SUB)
D969
DZ2J180M0L
IC965
STR-Y6763
DC-DC CONVERTER
Q935
RT1N441M-TP-1
Q933-935
POWER CONTROL
IC B/D
IC965
C946
0.1
D967
DA2J10100L
R968
10
3
4
2
1
R987
2.2k
0.5%
AMP SMPS
BOARD
(1/2)
(EX88)
R951
22k
0.1
2.8
R965
2.2
1/2W
HCD-EX66/EX88/EX99
13
0
C935
0.022
H
6
D943
FMX-22SL
16
17.8
C930
470p
G
12
VREF
OCP/BD
7
NC
FB
18.3
6
SS/OLP
3
2
C934
3.3
50V
7
VCC
D930
DZ2J300M0L
1
IC931
STR-X6768N
DC-DC CONVERTER
GND
C939
3300p
400V
IC B/D
IC931
D
R944
100k
3W
R943
100k
3W
ET902
(CHASSIS)
ET901
(CHASSIS)
D
11
VREF
(Page 35)
D932
DZ2J300M0L
C
10
8
NC
2
9
CL905
CL902
2.2
AMP SMPS
BOARD
(1/2)
A
B
R901
1.5M
1/2W
4
C905
0.22
250V
IC932
MM1431CURE
JL901
K
3
A
NEUTRAL
D901
D4SB60L-F
RECT
TH902
IC966
MM1431CURE
1
C903
470p
250V
JS908
AC IN ~
LIVE
C902
470p
250V
F901
T5AH
250V
CN901
2P
R989
10k
0.5%
C982
0.01
JL974
JW922
JL973
JW923
V2_GND
C983
0.1
V2_13.4V
HCD-EX66/EX88/EX99
5-21. PRINTED WIRING BOARD – REGULATOR Section (HCD-EX88) –
2
1
4
5
6
7
•
8
9
10
11
12
13
14
FAN701
DC FAN
JW706
JW716
Q705
CL700
BCE
Q711
R727
CL712
3
A701
IC703
CL710
JW712
CL708
CL715
CL709
CL716
CL707
CL706
JW726
D703
CL713
CL714
CN700
16
E
1
O
AMP SMPS
BOARD
CN601
(EX88)
(Page 34)
HCD-EX66/EX88/EX99
C706
CL711
C701
C716
R728
1
C702
6
JW700
R706
1
R744
IC701
R700
5
R747
R705
C714
R711
JW718
R703
C705
R725
R726
R724
R723
R722
D700
CL704
R701
Q701
B C E
BCE
R704
R702
JW728
BCE
JW708
C709
R713
Q703
L700
R719
R721
R720
R718
JW710
JW711
Q704 BCE
C700
R712
C707
R715
R716
R717
Q702
R710
JW704
BCE
D704
R729
R730
CL705
JL700
CL703
C710
BCE Q700
JW723
JW721
C708
R745
CL702
CL701
1
C713
JW715
6
Q706
C717
D
JW724
JW717
R746
Q707
IC700
JW720
C719
D701
R743
ECB
2
1
JW719
BCE
4
A700
JW714
JW703
R707
R708
R709
Q709
R731
R742
R734
5
5
C718
R733
BCE
C721
D702
R732
JW707
1
CN701 FB700
R740
R741 R738
R739
IC702
C703
C720
B C E
Q708
3
R737
FB701
CL718
CL717
JW702
B
REGULATOR BOARD (HCD-EX88)
BLK–
RED+
A
C
3
37
37
1-883-495-
12
(12)
HCD-EX66/EX88/EX99
5-22. SCHEMATIC DIAGRAM – REGULATOR Section (HCD-EX88) –
1
2
3
4
5
6
6
Q704
ISA1602AM1-T111-1EF
VBUS OCP DETECT
8
7
9
10
11
13
12
A
GND
IC B/D
IC703
SI-8008TM-TLS
GND
ADJ
SS
4
5
0
5.1
5.1
R720
1k
0.5%
R713
470k
C
0
0.7
C710
470
16V
C709
0.1
R711
100k
D700
RK36LF-A4
R710
10k
L700
47uH
3.6
R728
10k
3.6
SW
3
0.8
2
5.1
1
13.3
B
R722
1k
IN
IC703
VBUS +5V REG
R718
330
0.5%
C714
680
10V
R719
470
0.5%
C716
0.1
R721
3.3k
0.5%
R723
3.3
R724
3.3
R725
3.3
R726
3.3
Q702
Q703
2SC4154TP-1EF
2SC4154TP-1EF
POWER CONTROL POWER CONTROL
R727
3.3
IC701
2
3
4
5
E
R716
27k
0.5%
GND
VOUT
VADJ
4
5
IC700
SI-3010KM-TLS
+4V REG
R715
10k
0.5%
C707
0.1
C708
47
16V
C713
100
10V
3.2
R745
22k
R746
22k
0
D704
DZ2J047M0L
CL700
R730
100
3.2
R732
1k
0.2
Q711
RT1N141C-TP-1
DC DETECT
R729
100k
R742
1k
R734
22k
R709
10k
0.5%
CL717
CL718
FAN+
2
FAN-
3
FAN+
16
DC_DET
15
FAN_DET_CTRL
14
DC or FAN DET
13
VBUS_OCP
12
VBUS_ON
11
SUB_ON
10
GND
9
E+4V
8
GND
7
M+7V
6
GND
5
VBUS+5V
4
GND
3
9V
2
GND
1
V2
FAN701
DC FAN
+
Q709
2SC4154TP-1EF
FAN MOTOR DETECT
3.2
R737
220k
0.1
R738
3.3
R740
3.3
R739
3.3
R741
3.3
0.7
0
R731
100
C703
47
10V
C718
0.1
Q706
Q707
2SC4154TP-1EF
2SC4154TP-1EF
FAN MOTOR CONTROL FAN MOTOR CONTROL
C719
0.01
C720
0.01
C721
4.7
50V
CN700
16P
CL701
CL702
G
CL703
CL704
CL705
CL706
CL707
CL708
CL709
CL710
CL711
CL712
H
CL713
CL714
CL715
CL716
HCD-EX66/EX88/EX99
1
FB701
5.1
0.2
R708
15k
0.5%
FB700
R743
1k
C717
2.2
50V
R707
15k
0.5%
C700
470
16V
R733
1k
1
VIN
3
4
VCONT
2
13.3
1
13.3
F
IC700
CN701
3P
Q708
KTC3203Y-AT
FAN MOTOR REG
4.5
13.2
D702
DZ2J082M0L
GND
IC B/D
Q705
2SC4154TP-1EF
DC DETECT
JL700
R712
2.2k
6
R717
33k
0.5%
D701
DZ2J047M0L
1
D703
MC2838-T112-1
Q700
2SC4154TP-1EF
POWER CONTROL
R704
100k
ADJ
0.1
0.7
VOUT
R747
22k
1
C705
0.1
C702
0.1
R744
22k
GND
R702
10k
R706
4.7k
C706
10
50V
IC702
SI-3010KFEK
+7V REG
7
R705
4.7k
G
2
IC702
9
VIN
R703
4.7k
C701
10
50V
O 3
VC
R701
4.7k
12.4
1 I
3.2
R700
1k
13.2
13.3
D
IC B/D
IC701
KIA7809API-U/PF
+9V REG
Q701
KTA1273-Y-AT
POWER CONTROL
13.2
13.3
38
38
O
AMP SMPS
BOARD
(1/2)
CN601
(EX88)
(Page 35)
HCD-EX66/EX88/EX99
9
(Page 42)
EFX-MODULE
BOARD
CN802
(EX99)
EFX-MODULE
BOARD
CN801
(EX99)
REGULATOR
BOARD
CN700
(EX99)
Q
N
M
L
P
ET600
23
JW624
C676
JW934
JW922
JW923
R986
C977
R987
D981
CL908
IC965
1
7
C970
D984
C968
CL968
CL969
R992
D972
R971
R970
CL966
R969
B C E
D968
C972
R972
CL970
CL967
CL972
Q965
JW919
JW917
C969
R998
6
JW916
A930
CL974
D969
JW928
R965
D939
JW927
D975
2
A932
R968
CL907
C966
C967
JW903
D932
C911
C932
CL965
C975
D967
~
IC931
6
C971
R966
C938
R938
JW907
Q930
1
1 2
R979
D970 CL971
JW920
D937
R936
C933
R935
JW915
C934
BCE
C935
C939
D940
D930
7
C930
2
R978
JW908
C936
R941
D931
R933
D902
C914
~
C937
–
C909
E C B
D938
JW918
JW909
JW910
CL906
R942
C931
R930
C912
TH902
C907
+
R943
H
R944
Q932
R931
R974
R914
R975
R973
R939
JW926
CL975
4 3
IC966
CL973
JW905
JW904
JW906
D941 R934
R981
CL976
PH965
C E
R937
R945
D934
R984
R985
T903
R932
C910
JW902
JW935
D935
ET902
R989
PH930
C E
L902
CL905
L969
CL621
R620
C617
CL609
R627
JS908
C983
C982
JW901
CL602
CL931
ET931
C903
I
JR604
JL600
CL608
R630
PH931
C E
3
CL930
R946
T901
C902
R629
JW914
1 2
IC932
1
CL601
C986
ET930
R977
R947
R956
4 3
4
R671
C631
R957
R960
C947
JW929
R949
R950
ECB
Q602
JL601
R959
ECB
R951
Q933
G
D944
C989
D943
CL904
D985
Q934
L901
JL933
CL607
C677
5
IC603
BCE
JL977
C946
ECB
ECB
JW932
CL600
R967
1-883-486-
HCD-EX66/EX88/EX99
39
39
PANEL
BOARD
CN306
(EX99)
(Page 24)
JW636
CL659
R958
R961
JL902
JL901
Q935
F
R954
A931
R901
JW933
E
JW619
CL658
JL932
CL654
JW629
CL656
CL653
Q603
R600
CL652
CL655
CL657
R628
JW913
C943
JW912
F901
VDR901
C905
C950
L930
1
JL903
JW911
CL902
3
22
JR603
JW643
C944
CN901
JW614
C606
JW930
CL901
CL642
CL643
CL644
CL645
CL646
CL647
CL648
CL649
C611
R678
JL973
CL604
R604
R612
R679
JL974
R616
C658
R615
C609
JW622
1 4
JW616
CL640
CL639
JW625
JW617
8 5
IC601
JW645
JW611
CL641
JW931
ET901
CL638
C610
JW641
C678
C633
CL606
JW607
CL637
C607
R676
R610
R603
AC IN ~
E
CL636
CN600
JW647 R622
R606
C657
R611
C608
R674
R609
R675
R614 R602
CL625
C635
IC600
JW620
C612
R663
R623
C618
JW642
C615
C616
JR605
R613
1 4
C630
L604
C601
BCE
BCE
CL622
JW606
JW605
JW613
CL618
CL620
JW610
R677
CL624
C600
JW604
R673
8 5
CL605
CL623
CL650
JW649
6
CL619
12
11
CN603
CL617
JW632
5
JR600
CL614
JR601 JR602
R621
5
6
CN605
CL615
CL613
CL616
8
7
2
C629
CL612
1
2 JL602
6
1
C642
R625
R626
JW651
2
CN604
5
C613
1
R672
R608 R601
R605
C626
JW646
C643
D604
1
C649
C650
C648
JW637
IC602
CL611
JW618
R607
1
JW608
JW639
CN601
16
JW600
5
JW621
JW630
R617
JR606
R618
A600
C614
6
CL610
JW633
L603
L606
D603
C627
C628
C641
C652
R635
C645
C654
R645
C646
JW644
R633
C656
R669
R668
R651
R634
C665
JW612
R636
C651
JW602
JW603
JW650
C675
C666
R
JW615
L602
C655
R646
C647
JL618 CL635
C674
L608
RY600
JW601
C673
SPEAKERS
JW638
CL634 JL617
L
JW640
C672
I0PEDANCE8SE 3
L605
C664
C663
L601
R661
C653
R650
TB600
JW631
C
R664
R657
R659
CL633
R649 C661
R654
R637
CL632
JW609
R656
L607
C662
I0PEDANCEUSE 8
JW626
C670
C671
BCE
C640
BCE
C669
R643
BCE
R658 R665
TB601
SUBWOOFER
D
BCE
C668
R644
BCE
R655
R638
BCE
C667
R624
CL631
CN602
Q605 Q604
CL630 Q607 Q606 Q609 Q610
R639
R647
C660
C625
C659
R648
CL629
1
Q600
EFX-MODULE
BOARD
CN803
(EX99)
CL628
B
11
CL651
(Page 29)
REGULATOR
BOARD
CN701
(EX99)
CL627
6
A601
10
R988
R980
JW924
(Page 29)
8
Q601
A
(Page 29)
7
2
(Page 42)
6
1
5
R670
4
JW925
3
•
CL603
2
1
JW921
12
(12)
HCD-EX66/EX88/EX99
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
4
9V
3
GND
2
V2
1
5
CL645
R617
470k
CL648
R618
22k
Q601
2SC4154TP-1EF
POWER CONTROL
0
CL649
Q600
RT1N141M-TP-1
POWER CONTROL
CL650
CL651
0
R625
10k
0.5%
CN600
23P
E
M+7V
21
M-GND
20
E+4V
19
E-GND
18
VBUS+5V
17
VBUS-GND
16
VBUS-OCP
15
VBUS-ON
14
SUB-ON
13
MAIN-ON
12
PROTECT-F
11
PROTECT-S
10
V2-MONI
9
FAN LOW SPEED
8
AMP-RST
7
L-OUT
6
A-GND
5
R-OUT
4
A-GND
3
SW-OUT
2
FR-RELAY
1
CL652
R600
F
(EX99)
(Page 41)
1
V2_13.4V
V2_GND
PVDD_GND
PVDD_50V
CL653
L602
10uH
CL654
C641
1
63V
L607
0.6uH
C650
2200p
Q605
ISA1602AM1-T111-1EF
R656
220k
R657
220k
R658
220k
21.4
C669
47
0
Q607
ISA1602AM1-T111-1EF
R659
220k
R661
220k
R664
220k
21.4
0
Q610
ISA1602AM1-T111-1EF
R665
220k
R644
3.3
R649
3.3
C651
2200p
L605
0.6uH
CL627
R639
22k
C661
0.022
C652
2200p
CL629
CL628
C660
0.022
R648
3.3
IC B/D
CL659
R670
47k
C600
0.01
3.1
E
ET600
(CHASSIS)
R671
18k
CL600
IC603
R628
0.05 5W
IC603
PST3629NR
VOLTAGE DETECT
R629
2.2k
OUT
VDD
GND
CD
NC
1.7
C676
0.01
CL608
Q602
2SC4154TP-1EF
OVER CURRENT DETECT
CL609
CL607
0
2.8
C677
1000p
C629
470
63V
R630
2.2k
49.8
Q603
ISA1602AM1-T111-1EF
OVER CURRENT DETECT
C630
470
63V
R627
22k
CL601
JL601
C642
1
100V
R636
10k
0.5%
C646
1000
50V
C643
1
100V
R637
10k
0.5%
C647
1000
50V
L604
10uH
R638
10k
0.5%
C631
2200
63V
C617
0.22
50V
R620
100k
CL602
C645
1000
50V
C653
2200p
L608
0.6uH
C654
2200p
C663
0.022
RY600
C664
0.022
R645
3.3
R650
3.3
R646
3.3
R651
3.3
3
CL635
2
JL618
1
C648
1000
50V
C655
2200p
C656
2200p
C665
0.022
L606
0.6uH
R668
47
R669
47
R663
18k
0.5%
C613
1000p
R603
12k
R677
1k
R674
1k
R623
2.2k
0.5%
R609
22k
2
1
R613
47k
CL605
C610
10
50V
R675
1k
R614
22k
C606 R678
1k
0.18
R612
12k
7
C666
0.022
C658
47p
CL603
R679
1k
R615
12k
SPEAKERS
IMPEDANCEUSE 3ȍ
2
AMP SMPS
BOARD
(2/2)
(EX99)
6
OUT-D
5
PVDD-D
4
GND
3
OUT-C
2
PVDD-C
1
GND
PVDD-B
OUT-B
C615
1
3
GND
2
PVDD-A
C633
1
1
OUT-A
N
EFX-MODULE
BOARD
CN803
(EX99)
(Page 30)
M
EFX-MODULE
BOARD
CN802
(EX99)
(Page 30)
11.3
CN605
12P
CL612
1
CL615
C678
0.1
CL616
CL617
CL618
R621
10k
CL619
CL620
CL623
-
L
R
4
CL610
CL604
-
GND
CL611
CL625
+
+
5
8
CL606
IMPEDANCEUSE 8ȍ
6
JL602
R616
47k
SUBWOOFER
-
CN604
6P
CL614
2
(EX99)
(Page 43)
+
CN603
6P
CL613
3
NC
REGULATOR
BOARD
CN701
Q
(Page 41)
VCC
6.1
5.5
4
R604
47k
C612
0.1
6
6
3
CL624
FR_RELAY
6
GND1
C626
330
16V
VSS
IC601
IC601
NJM4558V-TE2
6
5.9
11.3
5
PRE AMP
5.5
C609
10
50V
R602
47k
R610
12k
5.5
4
R676
1k
8
6
H
PRE AMP
7
VSS
IC600
6
C611
0.18
VCC
5
6.2
R607
22k
5.5
R672
1k
IC600
NJM4558V-TE2
C607
10
50V
R611
47k
6
R605
22k
6.1
R673
1k
C657
47p
5
D603
DA2J10100L
CL622
R606
47k
FAN_DET_SIG_1
TB600
4P
4
CL634
D604
DA2J10100L
R601
47k
FAN_DET_SIG_2
4
CL633
R634
680 1W
JL600
C608
10
50V
DC_DET_SIG
3
CL621
50
0
R635
10k
0.5%
L603
10uH
GND
2
TB601
2P
JL617
CL658
1
CL632
C662
0.022
CL656
CL657
CN602
6P
CL630
R647
22k
C659
0.022
R643
3.3
CL655
R608
47k
HCD-EX66/EX88/EX99
C668
47
0
21.5
R633
680 1W
C618
100
10V
I
C649
2200p
C640
1
63V
C628
470
63V
R622
2.2k
0.5%
G
21.4
0
21.5
21.5
CL631
1k
C601
100p
MAIN_ON
R655
220k
R654
220k
C627
470
63V
3.6
AMP SMPS
BOARD
(2/2)
C625
47
16V
L601
10uH
5
(Page 26)
22
4
E
(EX99)
VCC-GND
1
PANEL
BOARD
(2/3)
CN306
23
2
D
VCC+9V
C667
47
R626
10k
0.5%
3
C
Q609
PISA1602AM1-T111-1EF
21.4
0
21.5
21.5
R624
100k
0.5%
11.7
C614
100
16V
2.8
0
21.5
CL646
CL647
Q606
ISA1602AM1-T111-1EF
21.4
Q604
ISA1602AM1-T111-1EF
21.4
4700p
VCC GND
4
4700p
5
3
C672
VBUS+5V
2
4700p
6
1
C671
7
CL644
C670
M+7V
VBUS GND
CL643
4700p
8
Q604-607,609,610
OVERLOAD DETECT
4700p
9
IC602
SI-3010KM-TLS
+12V REG
CL642
4700p
10
E+4V
MGND
IC602
CL641
C673
E GND
6
C674
11
CL640
C675
SUB_ON
IC B/D
CL639
VADJ
12
GND
VBUS_ON
CL638
VOUT
13
GND
VBUS_OCP
CL637
*
14
VIN
DC or FAN DET
CL636
12
(EX99)
(Page 43)
15
VCONT
P
16
13.3
B
REGULATOR
BOARD
CN700
FAN LOW SPEED
FR_RELAY_CTRL
11.7
CN601
16P
A
C635
1
C616
1
40
40
1
GVDD
2
INPUT-A
3
GND
4
INPUT-B
5
INPUT-C
6
INPUT-D
7
/RESET
8
CLK_SEL
9
/SD
10
/OTW1
11
/OTW2
12
/CLIP
L
EFX-MODULE
BOARD
CN801
(EX99)
(Page 30)
HCD-EX66/EX88/EX99
1
2
3
4
5
6
7
8
9
11
10
12
13
14
A
CL904
E
F901
T6.3AH
250V
JL901
B
C905
0.22
250V
R901
1.5M
1/2W
VDR901
JL903
4
3
4
3
1
2
1
2
~
C907
0.33
250V
~
C911
0.01
250V
C909
1000p
250V
C
T901
DC-DC CONVERTER
TRANSFORMER (MAIN)
C914
390
450V
CL905
2
CL902
CL901
E
E
(EX99)
(Page 40)
ET902
(CHASSIS)
ET901
(CHASSIS)
R943
100k
3W
R944
100k
3W
IC931 IC B/D
SS/OLP
FB
OCP/BD
6.1
3.4
C932
1
100V
D932
DZ2J300M0L
4.9
Q932
2SA1364-T111-1DE
POWER ON/OFF
D930
DZ2J300M0L
1
2
3
4
VCC
22.9
5
GND
C934
3.3
50V
6
S
C931
1000p
1.5kV
*
7
D
C939
3300p
400V
D940
SARS03
IC931
STR-X6768N
DC-DC CONVERTER
D
9
10
8
11
7
12
6
13
CL906
GND1
C937
47
100V
D941
D1NL20U-TR2
17.2
E
R930
0.22
2W
R933
100
0.5%
C935
0.022
R945
22
R941
10k
R942
10k
C930
470p
R938
3.3k
R934
8.2k
D931
DA2J10100L
R931
0.22
2W
R936
2.2k
C933
220p
Q930
2SC4154TP-1EF
F
D934
DZ2J150M0L
0.4
R937
1k
D938
DA2J10100L
R939
2.2k
R974
1.8k
D937
DZ2J06200L
JW930
C950
22
63V
2
17
1
18
R958
4.7k
0.5%
D944
DZ2J180M0L
2
4
R946
1k
C989
22
63V
R949
10k
PVDD_50V
JW932
JL933
JW933
CL930
R957
4.7k
0.5%
PVDD_GND
CL931
E
R959
33k
0.5%
ET930
(CHASSIS)
3
4
IC932
2
1
VOLTAGE DETECT
R960
2.2k
0.5%
R977
10k
1
3
R975
1.8k
R956
22k
28.2
1
D935
DA2J10100L
R973
2k
C947
0.1
R950
1k
D985
MC2838-T112-1
2
R947
3.3k
Q933
RT1N441M-TP-1
1
R951
22k
0.1
D939
DA2J10100L
JL977
JW921
JL974
JW922
JL973
JW923
(Page 40)
MAIN_ON
0.1
30.1
Q934
2SC4154TP-1EF
2.7
C946
0.1
CL970
C972
220p
I
HCD-EX66/EX88/EX99
C968
1
R971
15k
0.5%
R972
1k
0.5%
D972
DZ2J220M0L
5
11
4
R970
100k
10
C986
2700
16V
D981
RK49LF-T1
9
R978
4.7
2
8
1
7
R980
1k
R984
220
R981
10k
0.5%
R992
100
R967
47k
0.5%
C969
4.7
PH965
PS2561AL1-1-V-W
C977
0.047
R986
4.7k
0.5%
CL976
CL971
4
1
CL973
CL972
3
2
CL974
C970
4700p
CL975
R979
1k
IC966
VOLTAGE DETECT
41
R985
4.7k
0.5%
41
3
4
2
1
R987
2.2k
0.5%
R989
10k
0.5%
C982
0.01
V2_GND
C983
0.1
L969
10uH
R988
0
2.1
NC
CL968
D968
DZ2J220M0L
C971
22
100V
12
VREF
0.3
17.6
R969
4.7k
D975
EG01C LF-F7
6
NC
BD
R966
0.82 1W
25.3
D970
D1NL20U-TR2
10.8
2
5
5.2
6
GND
FB/OLP
21.5
CL969
CL966
7
H
CL965
21.5
4
VCC/OVP
C967
150p
2kV
CL967
Q965
+22V REG
Q965
2SC5053T100Q
T903
DC-DC CONVERTER
TRANSFORMER (SUB)
C975
470p
500V
K
1
S/GND
3
D
R998
100k
1W
A
C966
0.1
IC965
STR-Y6763
DC-DC CONVERTER
Q935
RT1N441M-TP-1
Q933-935
POWER CONTROL
IC966
MM1431CURE
IC965 IC B/D
*
D967
DA2J10100L
D969
DZ2J180M0L
D984
UDZSUSTE-1730B
G
R968
10
JS908
R965
2.2
1/2W
AMP SMPS
BOARD
(1/2)
(EX99)
R961
1k
2.7
C938
4700p
C936
470p
15
C944
1000
63V
PH931
PS2561AL1-1-V-W
Q930
R935
10 VOLTAGE DETECT
1.3
4
C943
1000
63V
JL932
R954
0
PH930
PS2561AL1-1-V-W
4
3
R932
220
14
JW931
L930
2.2uH
16
23.2
22.9
5
D943
FMX-22SL
2.2
AMP SMPS
BOARD
(1/2)
R914
0.1
1W
C912
0.01
250V
L902
L901
JL902
K
3
VREF
1
NC
LIVE
NEUTRAL
C910
100p
250V
D902
D10XB60 F
RECT
TH902
A
AC IN ~
C903
470p
250V
IC932
MM1431CURE
CN901
2P
C902
470p
250V
ET931
(CHASSIS)
V2_13.4V
HCD-EX66/EX88/EX99
5-26. PRINTED WIRING BOARD – REGULATOR Section (HCD-EX99) – • See page 20 for Circuit Boards Location.
2
1
4
5
6
7
8
9
10
11
12
13
14
FAN701
DC FAN
B
BLK–
RED+
A
Q711
R727
R728
1
C702
3
C705
R724
R723
R725
R726
C716
R706
A701
C714
CL710
C706
CL711
C701
IC703
R700
1
Q701
B C E
5
R744
IC701
JW702
JW700
R747
R705
CL709
JW712
JW704
JW718
R722
D700
CL704
R704
JW723
BCE
R703
R702
JW728
BCE
JW708
BCE Q700
R701
Q704 BCE
Q703
JW711
C709
R713
R712
C707
R715
R746
R716
R745
JW720
Q702
L700
R719
R718
R720
R721
JW710
C700
C710
6
CL708
JW726
CL707
CL713 CL714 CL715
D703
CL706
CL716
CL712
CN700
16
1
Q
P
AMP SMPS
BOARD
CN602
(EX99)
AMP SMPS
BOARD
CN601
(EX99)
(Page 39)
(Page 39)
HCD-EX66/EX88/EX99
R711
R710
CL702
CL722
1
CL705
BCE
D704
Q706
CL700
1
C708
R717
JW719
C717
CL703
BCE
2
JW724
JW717
C713
C703
JL700
CL721
CL701
6
JW715
6
R731
JW701
ECB Q705
CL720
CN701
CL717
E
R732
CL719
R730
4
A700
1
JW721
D705
R729
C723
CL718
R707
R750
Q712
D706
D
5
IC700
R751
Q707
C719
D701
Q708
5
ECB
C722
R734
ECB
C724
R753
R733
BCE
C718
R735
R749
Q710
C721
D702
R736
BCE
IC702
R709
1
CN702 FB700
R742
R743 R740
R741
R708
R752
C720
B C E
Q709
3
R739
FB701
CL724
CL723
JW714
JW706
R748
C
3
•
42
42
1-883-487-
12
(12)
HCD-EX66/EX88/EX99
5-27. SCHEMATIC DIAGRAM – REGULATOR Section (HCD-EX99) –
2
1
4
3
6
5
7
8
10
9
11
12
13
14
15
A
Q704
ISA1602AM1-T111-1EF
VBUS OCP DETECT
6
GND
IC B/D
R722
1k
GND
ADJ
SS
3
4
5
0.8
0
3.6
SW
2
5
1
13.2
VBUS +5V REG
IN
IC703
SI-8008TM-TLS
IC703
R720
1k
0.5%
3.6
0.7
Q702
2SC4154TP-1EF
POWER CONTROL
IC701
R747
22k
4
5
GND
IC B/D
GND
VOUT
VADJ
4
5
IC700
SI-3010KM-TLS
+4V REG
F
C707
0.1
C708
47
16V
C713
100
10V
Q706
2SC4154TP-1EF
DC DETECT
R745
22k
Q709
KTC3203Y-AT
FAN MOTOR REG
13.1
4.5
JL700
R746
22k
D704
DZ2J047M0L
CL700
3.2
3.2
0
0.1
C717
2.2
50V
R731
100k
Q711
RT1N141C-TP-1
DC DETECT
R732
100
C722
1
50V
R734
1k
C723
1
50V
0.8
Q705
2SC4154TP-1EF
SPEAKER RELAY DRIVER
C703
47
10V
D706
MC2840-T112-1
D705
MC2840-T112-1
0.1
R730
10k
R750
15k
0.5%
R709
10k
0.5%
Q707
2SC4154TP-1EF 0.7
FAN MOTOR CONTROL
0
R751
47k
R729
2.2k
R707
15k
0.5%
C700
470
16V
R715
10k
0.5%
0
R733
100
0
C724
10
50V
R752
100k
R753
10k
R708
47k
Q712
2SC4154TP-1EF
FAN MOTOR CONTROL
R735
1k
R736
1k
FB700
R748
1k
Q710
2SC4154TP-1EF
FAN MOTOR DETECT
3.2
R739
220k
0.1
5
R749
22k
0.2
0.7
C718
0.1
C719
0.01
C720
0.01
C721
4.7
50V
CL723
CL724
6
NC
5
FR_RELAY
4
FAN_DET_SIG_1
3
FAN_DET_SIG_2
2
DC_DET_SIG
1
GND
Q
AMP SMPS
BOARD
(1/2)
CN602
(EX99)
(Page 40)
R740
3.3
R742
3.3
R741
3.3
R743
3.3
CL703
CL704
CL705
CL706
CL707
CL708
CL709
CL710
CL711
CL712
CL713
CL714
CL715
CL716
H
43
43
1
FAN+
2
FAN-
3
FAN+
FAN701
DC FAN
+
Q708
2SC4154TP-1EF
FAN MOTOR CONTROL
CL702
G
CN702
3P
FB701
CL701
HCD-EX66/EX88/EX99
CN701
6P
R717
33k
0.5%
1
VIN
3
4
2
13.2
VCONT
IC700
1
13.2
E
R716
27k
0.5%
D701
DZ2J047M0L
3
D702
DZ2J082M0L
ADJ
2
D703
MC2838-T112-1
VOUT
1
R712
2.2k
6
CL721
CL722
Q700
2SC4154TP-1EF
POWER CONTROL
0.7
R702
100k
CL720
IC702
SI-3010KFEK
0.1
R701
10k
CL719
1
C705
0.1
C702
0.1
CL718
+7V REG
GND
R706
4.7k
C706
10
50V
R744
22k
7
R705
4.7k
CL717
VIN
D
R704
4.7k
R725
3.3
IC702
9
3
3.2
R703
4.7k
O
2
C701
10
50V
12.4
G
R723
3.3
R724
3.3
R727
3.3
VC
I
R719
470
0.5%
R721
3.3k
0.5%
R726
3.3
IC B/D
13.2
13.1
1
R700
1k
R718
330
0.5%
C714
680
10V
Q703
2SC4154TP-1EF
POWER CONTROL
IC701
KIA7809API-U/PF
+9V REG
Q701
KTA1273-Y-AT
POWER CONTROL
13.1
13.2
C710
470
16V
C709
0.1
R711
100k
C
L700
47uH
D700
RK36LF-A4
R713
470k
0
C716
0.1
5.2
B
R710
10k
R728
5.2 10k
CN700
16P
16
FAN LOW SPEED
15
FR_RELAY_CTRL
14
DC or FAN DET
13
VBUS_OCP
12
VBUS_ON
11
SUB_ON
10
E GND
9
E+4V
8
MGND
7
M+7V
6
VBUS GND
5
VBUS+5V
4
VCC GND
3
9V
2
GND
1
V2
P
AMP SMPS
BOARD
(1/2)
CN601
(EX99)
(Page 40)
HCD-EX66/EX88/EX99
• IC Block Diagrams
IC301 BA5826HFP-E2 (BD76 Board (1/2))
IC307 PST3629NR (PANEL Board (1/3))
IC603 PST3629NR (AMP SMPS Board (1/2))
(HCD-EX66)
(HCD-EX66)
(HCD-EX88)
(HCD-EX99)
IC101 LC786950T-US-H (BD76 Board (1/2))
SLCO
LRVSS
RCHO
LRREF
LCHO
LRVDD
XVDD
XIN
XOUT
XVSS
CONT4
DOUT
DVDD
DVSS
DVDD15
PCMREQ
PCMDATA
PCMBCK
PCMLRSY
DVDD
VO1– 1
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
CLOCK
GENERATOR
PHLPF 4
SLICE
LEVEL
CONTROL
8FS DIGITAL FILTER/
1BIT DAC
54 AD_LRCK (STREQ)
AUDIO CONTROL
MUTE/DE-EMPHASIS/
ATTENUATION CONTROL/
BASS/TREBLE/
HFC FILTER
SLCISET 9
VREF
MP3
ENCODER
INTERPOLATION MUTE
EIN 13
JITTER
PCNCNT 15
APC
SYNCHRONIZATION
DETECTION
EFM
DEMODULATION
TE 16
D/A
TEIN 17
LDD 18
LDS 19
50 CONT2
GND 8
MUTE
21 VCC
VCC
20 IN3’
IN2’ 9
19 IN3
IN2 10
LEVEL
SHIFT
LEVEL
SHIFT
D.BUFF
47 RESB
D.BUFF
18 VO3+
VO2+ 11
MCU
I/F
SUBCODE
DECODER
SERVO
CONTROL
A/D
51 CONT1
48 INTB0
TEXT
DECODER
GND 3
22 VCC
30 GND
MUTE 7
GND 29
49 INTB1
ROM
DECODER
ERROR CORRECTION
FIN 14
MEMORY
1M BIT
4 NC
23 BIAS
VCC
REGOUT 6
52 CONT0
SRC
5 CD
VREF
REGB 5
53 TEST0
MP3, WMA, AAC
DECODER
TES, HFL,
DEFECT
JITTC 12
VDD 2
–
+
55 AD_BCK (STCK)
MONITOR
VREF 11
OUT 1
24 IN4’
56 AD_DATA (STDATA)
RF
SIGNAL
PROCESSOR
RFMON 10
25 IN4
THERMAL
SHUT-DOWN
REGULATOR
BIAS TRAP
58 DEFECT (DATA)
STREAM CONTROL/AUDIO INPUT
DIN 8
D.BUFF
LEVEL
SHIFT
RESET 4
57 TEST1
MEMORY I/F
BIN 7
26 VO4+
IN1 3
59 FSEQ (DATACK)
AUDIO OUTPUT
CONTROL
AIN 5
CIN 6
D.BUFF
LEVEL
SHIFT
D.BUFF
60 C2F (LRSY)
MP3/PCM OUTPUT CONTROL
RFOUT 2
LPF 3
27 VO4–
VO1+ 2
REGULATOR
LPF
EFMIN 1
28 GND
D.BUFF
46 DO
45 DI
VO2– 12
GND 13
44 CL
OPOUT 14
D.BUFF
D.BUFF
17 VO3–
16 RESETt
15 OPIN
43 CE
42 DVSS
DOUT CONTROL
AVSS 20
PLL3
CD PLL
41 DVDD
IC306 BD3419FS-SE2 (PANEL Board (2/3))
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
A1
A2
FIL
GND
SDATA
SCLK
VCC
OUT-R
SB-R
SURR
SB-L
OUT-L
BASSB-R
BASSA-R
BASSA-L
FDO
TDO
SLDO
SPDO
VVSS1
PDOUT1
PDOUT0
PCKIST
VVDD1
CONT5 (M-MUTE)
LIMIT-SW (CONT3)
STREQ (DEFECT)
STCK (FSEQ)
STDATA (C2F)
DVDD
DVSS
DVDD15
VVDD3
VVSS3
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18 17
VCC/2
I2C BUS LOGIC
BASSB-L
21
AVDD
PORT CONTROL
VCC
SURROUND
TREBLE/BASS
INPUT GAIN
INPUT SELECTOR
HCD-EX66/EX88/EX99
44
44
2
3
4
5
6
7
8
9
10
11
12
13
14
15 16
TC-R
TC-L
TUNER-R
TUNER-L
CD/USB-R
CD/USB-L
PC-IN-R
PC-IN-L
SEL-L
SEL-R
VOL-R
VOL-L
TRE-L
TRE-R
1
B2
VOLUME
B1
VOLUME
HCD-EX66/EX88/EX99
GVDD_B
GVDD_A
BST_A
OUT_A
OUT_A
PVDD_A
PVDD_A
GND_A
59
58
57
56
55
54
53
52
51
50
49
1
2
3
4
5
6
7
8
9
VREF
OUT2
RNF
OUT1
VM
VCC
FIN
GND
RIN
CONTROL LOGIC
GND_A
OUT_A
PVDD_A
GND
60
PVDD_A
GND
61
OUT_A
NC
62
BST_A
NC
63
GVDD_A
NC
64
GVDD_B
NC
TSD
PSU_REF
IC800 TAS5630BPHDR (EFX-MODULE Board) (HCD-EX99)
VDD
IC303 BA6956AN (PANEL Board (3/3))
OC_ADJ 1
VREG
CLIP
READY
OTW1
OTW2
IC304 MM1923DTRE (PANEL Board (3/3))
SD
M2
VIN 2
M3
BIAS
REFERENCE
/RESET 2
SOFT
START
AMP
STARTUP
CONTROL
C_STARTUP 3
GND 3
POWER-UP
RESET
PROTECTION & I/O LOGIC
M1
CONT 1
TEMP
SENSE
GVDD_C
GVDD_A
GVDD_B GVDD_D
OVER-LOAD
PROTECTION
CB3C
4
4
4
PPSC
THERMAL
SHUT DOWN
UVP
CURRENT
SENSE
PVDD_X
OUT_X
GND_X
OSCILLATOR
CURRENT
LIMITER
VO 4
GVDD_A
PWM
ACTIVITY
DETECTOR
CS 5
4
PSU_FF
BST_A
PVDD_X
PVDD_A
GND
PWM
RECEIVER
TIMING
CONTROL
CONTROL
GATE-DRIVE
GND_A
IC502 RS5B800-0002E2 (TUNER Board)
18 X1
17 CP1
GND 1
Digital Signal Processing
VDDRF 2
IISD
AGC
AMP
Digital
Mixer
FM
Demodulator
Stereo
Decoder
AGC
AMP
Digital
AGC
AM
Demodulator
RDS
Decoder
AMP
ADC
Station
Detector
Digital Filters
IIS
Generator
RSSI
Calculation
INPUT_D 11
ROUT
14 ROUT
LRCK
Image
Control
ARF1 6
+
TIMING
CONTROL
CONTROL
43 PVDD_B
PWM
RECEIVER
/SD 15
/OTW1 16
36 OUT_C
GVDD_D
BST_D
PWM
RECEIVER
SD
TIMING
CONTROL
CONTROL
GATE-DRIVE
OTW1
45
45
23
24
25
26
27
28
29
30
31
32
GVDD_C
GVDD_D
BST_D
OUT_D
OUT_D
PVDD_D
PVDD_D
GND_D
GND_D
22
GND
PVDD_D
21
GND
PVDD_D
20
M3
OUT_D
19
M2
OUT_D
18
M1
BST_D
17
READY
IIC/RDSI 8
LA 9
CK 10
GVDD_D
GVDD_C
M3
M2
M1
READY
CLIP
Serial Interface/Registers
XOSC
/CLIP
Clock
Generator
OUT_D
GND_D
/OTW2
LOSC
35 GND_C
34 GND_C
PVDD_D
OTW2
AM
TUNE
37 OUT_C
GATE-DRIVE
OSC_IO- 14
12 GND
41 BST_B
38 PVDD_C
TIMING
CONTROL
CONTROL
OSC_IO+ 13
13 DA
42 PVDD_B
40 BST_C
39 PVDD_C
FREQ_ADJ 12
BCLK
45 OUT_B
44 OUT_B
GATE-DRIVE
GVDD_C
+
-
ANALOG
LOOP FILTER
47 GND_B
46 GND_B
11 VDD
AM LNA
HCD-EX66/EX88/EX99
ANALOG
LOOP FILTER
PWM
RECEIVER
15 LOUT
DAC
ADC
GNDRF 5
16 IISD
6
7
8
9
10
LOUT
Filter
FM LNA
ARF2 7
VI_CM
GND
AGND
VREG
INPUT_C
+
-
ANALOG COMPARATOR MUX
INPUT_B 5
ANALOG
LOOP FILTER
+
ANALOG INPUT MUX
INPUT_A 4
ANALOG
LOOP FILTER
19 X2
FRF1 4
48 GND_A
GVDD_B
20 VDD
CP2 3
OUT_A
33 GND_D
HCD-EX66/EX88/EX99
OUT_A
OUT_A
PVDD_A
PVDD_A
GND_A
54
53
52
51
50
49
GND_A
OUT_A
VCONT
BST_A
55
VIN
GVDD_A
56
GND
GVDD_B
57
SI-3010KM-TLS (AMP SMPS Board (1/2)) (HCD-EX66)
SI-3010KM-TLS (REGULATOR Board) (HCD-EX88)
SI-3010KM-TLS (REGULATOR Board) (HCD-EX99)
VOUT
GND
58
IC700
IC602
IC700
IC602
IC700
VADJ
GND
59
PVDD_A
NC
60
PVDD_A
NC
61
OUT_A
NC
62
BST_A
NC
63
GVDD_A
PSU_REF
64
GVDD_B
VDD
IC800 TAS5613APHDR (EFX-MODULE Board) (HCD-EX88)
IC800 TAS5611APHDR (EFX-MODULE Board) (HCD-EX66)
5
4
3
2
1
OC_ADJ 1
REF
VREG
+
–
CLIP
READY
OTW1
OTW2
SD
GND
GVDD_C
GVDD_B GVDD_D
CB3C
4
4
4
PPSC
CURRENT
SENSE
IC702 SI-3010KFEK (AMP SMPS Board (1/2)) (HCD-EX66)
IC702 SI-3010KFEK (REGULATOR Board) (HCD-EX88)
IC702 SI-3010KFEK (REGULATOR Board) (HCD-EX99)
PVDD_X
OUT_X
GND_X
OSCILLATOR
4
5
4
3
2
1
GVDD_A
PWM
ACTIVITY
DETECTOR
REF
BST_A
PVDD_X
PVDD_A
GND
PWM
RECEIVER
TIMING
CONTROL
CONTROL
GATE-DRIVE
+
–
PSU_FF
VC
OVER-LOAD
PROTECTION
VIN
STARTUP
CONTROL
GVDD_A
GND
/RESET 2
TEMP
SENSE
6
VOUT
M3
TSD
UVP
ADJ
M2
C_STARTUP 3
POWER-UP
RESET
PROTECTION & I/O LOGIC
M1
OUT_A
GND_A
48 GND_A
GVDD_B
6
7
8
9
10
+
-
ANALOG
LOOP FILTER
INPUT_D 11
PWM
RECEIVER
+
41 BST_B
IC703 SI-8008TM-TLS (AMP SMPS Board (1/2)) (HCD-EX66)
IC703 SI-8008TM-TLS (REGULATOR Board) (HCD-EX88)
IC703 SI-8008TM-TLS (REGULATOR Board) (HCD-EX99)
40 BST_C
39 PVDD_C
PWM
RECEIVER
TIMING
CONTROL
CONTROL
GATE-DRIVE
38 PVDD_C
37 OUT_C
6
36 OUT_C
35 GND_C
34 GND_C
GVDD_D
BST_D
OSC_IO+ 13
ON/OFF
SOFT
START
PVDD_D
OSC_IO- 14
TIMING
CONTROL
GATE-DRIVE
HCD-EX66/EX88/EX99
–
+
+
ERROR AMP
31
32
46
46
OUT_D
OUT_D
PVDD_D
PVDD_D
GND_D
THERMAL
PROTECTION
REFERENCE
VOLTAGE
1
2
3
4
5
SS
30
LATCH
&
DRIVER
ADJ
29
RESET
COMPARATOR
–
+
33 GND_D
GND_D
28
BST_D
PVDD_D
27
GVDD_D
PVDD_D
26
GVDD_C
OUT_D
25
GND
OUT_D
24
GND
BST_D
23
M3
GVDD_D
GVDD_C
22
M2
M3
21
M1
M2
20
READY
M1
19
/CLIP
READY
18
/OTW2
CLIP
17
OSCILLATOR
OUT_D
GND_D
OTW1
OVERCURRENT
PROTECTION
GND
CONTROL
PREG
SW
PWM
RECEIVER
SD
OTW2
/OTW1 16
42 PVDD_B
GVDD_C
FREQ_ADJ 12
/SD 15
45 OUT_B
44 OUT_B
GATE-DRIVE
43 PVDD_B
+
-
ANALOG
LOOP FILTER
TIMING
CONTROL
CONTROL
IN
VI_CM
GND
AGND
VREG
INPUT_C
TSD
47 GND_B
46 GND_B
GND
INPUT_B 5
ANALOG
LOOP FILTER
+
ANALOG COMPARATOR MUX
ANALOG
LOOP FILTER
ANALOG INPUT MUX
INPUT_A 4
HCD-EX66/EX88/EX99
IC930 STR-Y6766 (AMP SMPS Board (2/2)) (HCD-EX66)
D 1
STARTUP
DRIVER
S/GND 2
VCC/OVP 3
OVER CURRENT
PROTECTION/
BOTTOM-SKIP
UNDER VOLTAGE
LOCK OUT/
REGULATOR/
CONSTANT CURRENT
LOGIC
GND 4
FB/OLP 5
LATCH
FEEDBACK/
STANDBY
OVERLOAD
PROTECTION
BD 6
BOTTOM
DETECTION
NC 7
OSCILLATOR
IC931 STR-X6768N (AMP SMPS Board (2/2)) (HCD-EX88)
IC931 STR-X6768N (AMP SMPS Board (2/2)) (HCD-EX99)
D 1
DRIVE
REG
PROTECTION
LATCH
REG &
ICONST
R
DELAY
BURST
CONTROL
Q
S 2
S
GND 3
START
STOP
BURST
OVP
VCC 4
SS/OLP 5
FB
Q
S
FB 6
Q
OCP
R
S
R
OSC
BSD
Max ON
BD
OCP/BD 7
OLP
BOTTOM SELECTER
COUNTER
SOFT START
47
HCD-EX66/EX88/EX99
• IC Pin Function Descriptions
BD76 BOARD (2/2) IC901 LC87F1JJ2AU-SQFP-H (USB CONTROL)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21, 22
23 to 25
26
27
28
29, 30
31
32
33
34 to 36
37
38
39
40
41
42
43
44
45
46
47
48
48
Pin Name
P73
RES
XT1
XT2
VSS1
CF1
CF2
VDD1
SO0
SI0
SCK0
SO1
SI1
SCK1
P16
P17
MCLKI
MCLKO
VDD2
VSS2
P00, P01
DBGP0 to DBGP2
SDAT
BCLK
LRCK
P20, P21
P22
P23
P24
P25 to P27
UHD–
UHD+
VDD3
VSS3
UFILT
AFILT
P32
URX1
UTX1
P70
P71
P72
I/O
O
—
—
O
—
I
O
—
O
I
I/O
O
O
O
I
O
O
O
—
—
O
O
I
I
I
O
O
O
O
O
I/O
I/O
—
—
I
O
O
I
O
I
I
O
Description
Not used. (Open)
USB control reset pin
Not used. (Connect to VDD)
Not used. (Open)
Ground
Oscillation signal input (12 MHz)
Oscillation signal output (12 MHz)
Power supply pin (+3.3 V)
CD digital signal processor serial data communication signal output
CD digital signal processor serial data communication signal input
CD digital signal processor clock communication signal input/output
Not used. (Open)
Not used. (Open)
Not used. (Open)
CD digital signal processor enable communication signal input
Not used. (Open)
Not used. (Open)
Not used. (Open)
Ground
Not used. (Open)
For debagger pin
USB record MP3 serial data signal input
USB record MP3 serial data shift clock signal input
USB record MP3 serial data word clock signal input
Not used. (Open)
USB playback serial data signal output
USB record MP3 serial data request signal output
USB playback serial data communication clock signal output
Not used. (Open)
USB D– serial data input/output
USB D+ serial data input/output
Ground
USB interface PLL filter circuit connection pin (Fixed at L in this set)
Not used. (Open)
Not used. (Open)
System controller input communication signal input
System controller output communication signal output
USB playback serial data request signal input
USB controller command processing cancel signal input
Not used. (Open)
HCD-EX66/EX88/EX99
PANEL BOARD (1/3) IC302 LC87F7DJ2CVU-QIP-H (SYSTEM CONTROL)
Pin No.
1
2
3
4
5
6
7
8
9
10
11
I/O
O
O
O
O
O
O
O
O
O
O
I
14
15
16
17
Pin Name
O-CD-RST
O-CD-DI
O-CD-CE
O-USB-RST
O-DIMMER
I2C-FUNC-DATA
I2C-FUNC-CLK
I2C-TU-DATA
I2C-TU-CLK
O-VOL-LED
I-RST
Sub Clock
(32.768kHz)
Sub Clock
(32.768kHz)
VSS1
Main Clock(20MHz)
Main Clock(20MHz)
VDD1
18
I-CD-OP/CL
I
19
20
21
22
23
24 to 26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45 to 53
54
55
56 to 79
80 to 82
83 to 86
87
88
89
90
91
92
93
94
I-MODEL
I-SUFFIX
I-SIGNAL-LEVEL
I-LED-LEVEL
I-VACS
I-KEY2 to I-KEY0
I-PROTECT-F
I-AC-CUT
I-RMC(SIRCS)
O-FAN-LOW-SPEED
O-FR-RELAY
O-SW-MUTE
O-AMP-RST
I-V2-MONI
I-PROTECT-S
O-HP-MUTE
O-MAIN-ON
O-SUB-ON
O-VBUS-ON
I-VBUS-OCP
I-RDSI
O-STBY-SW
O-LCD-LED
NC
SEG0 to SEG8
VDD2
VSS2
SEG9 to SEG32
LCD V3 to LCD V1
COM3 to COM0
O-CD-M–
O-CD-M+
VSS3
VDD3
O-CD-ON
O-USB-SLEEP
O-USB-TXD
I-USB-RXD
I
I
I
I
I
I
I
I
I
O
O
O
O
I
I
O
O
O
O
I
I
O
O
—
O
—
—
O
—
O
O
O
—
—
O
O
O
I
12
13
Description
System reset signal output for the CD-MP3 processor
Serial data output for the CD-MP3 processor
Chip enable signal output for the CD-MP3 processor
System reset signal output for the USB control
Volume LED dimmer control signal output
Serial data output for the electrical volume
Serial data transfer clock signal output for the electrical volume
Serial data output for the AM/FM DET
Serial data transfer clock signal output for the AM/FM DET
Volume LED ON/OFF signal output
Reset signal input (L: reset)
I
Sub system clock signal input (32.768 kHz)
O
Sub system clock signal output (32.768 kHz)
—
I
O
—
Ground
Main system clock signal input (20 MHz)
Main system clock signal output (20 MHz)
Disc tray close/open detection signal input/headphones with/without detection signal input
from the CD mechanism deck
Model setting pin
Destination setting pin
Audio level detection signal input
Volume LED level detection signal input
VACS level detection signal input
Key signal input (A/D input)
Fast protection detection signal input (L: abnormal, H: normal)
AC cut detection signal input
Remote control signal input from the remote control signal receiver
Fan speed control signal output
Speaker relay ON/OFF signal output (HCD-EX99)
Subwoofer ON/OFF signal output (HCD-EX99)
Amplifier reset signal output
V2 power supply monitor signal input
Standard protection detection signal input (L: abnormal, H: normal)
Headphones mute ON/OFF signal output (L: mute OFF, H: mute ON)
Main power supply ON/OFF control signal output
Sub power supply ON/OFF control signal output
VBUS power supply ON/OFF control signal output
VBUS overcurrent detection signal input (L: abnormal, H: normal)
RDS detection signal input
Power supply control at standby mode
LCD back light LED ON/OFF control signal output
Not used. (Open)
Segment drive signal output for the liquid crystal display panel
Ground
Segment drive signal output for the liquid crystal display panel
Bias power supply for the liquid crystal display panel
Common drive signal output for the liquid crystal display panel
CD motor drive (–) signal output for the CD mechanism deck
CD motor drive (+) signal output for the CD mechanism deck
Ground
Digital power supply control signal output for the CD-MP3 processor
Sleep control signal output for the USB control
USB TX signal output for the USB control
USB RX signal input from the USB control
49
HCD-EX66/EX88/EX99
Pin No.
95 to 97
98
99
100
50
Pin Name
DGBP0 to DGBP2
O-CD-CL
I-CD-DO
O-CD-M-MUTE
I/O
I
O
I
O
Description
For debagger pin
Clock signal output for the CD-MP3 processor
Serial data input from the CD-MP3 processor
CD motor drive ON/OFF mute control signal output for the CD motor/coil driver
HCD-EX66/EX88/EX99
SECTION 6
EXPLODED VIEWS
Note:
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• The mechanical parts with no reference
number in the exploded views are not supplied.
6-1.
• Abbreviation
AR
: Argentina model
E2
E4
EA
MX
: Mexican model
• Color Indication of Appearance Parts Example:
KNOB, BALANCE (WHITE) . . . (RED)
↑
↑
Parts Color Cabinet’s Color
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
OVERALL SECTION
top panel section
2
not supplied
(TUNER board)
#1
4
3
5
1
#1
#1
A
not supplied
#1
#1
#1
#1
not supplied
#1
2
6
#1
#1
#1
#1
not supplied
not supplied
#1
FAN701
A
7
2
#1
#1
chassis section
front panel section
Ref. No.
#1
Part No.
Description
1
2
03
03
03
4-263-388-01
3-363-099-32
1-834-966-41
1-837-309-21
1-837-312-11
CASE (L), SIDE
SCREW (CASE 3 TP2)
CORD, POWER-SUPPLY (E2, E4, E51)
CORD, POWER-SUPPLY (EA)
CORD, POWER-SUPPLY (AR)
03
04
1-837-344-11
1-569-008-33
CORD, POWER-SUPPLY (MX)
ADAPTOR, CONVERSION (E2, E4, E51)
2
Remark
Ref. No.
Part No.
Description
5
5
5
6
7
4-263-387-01
4-263-387-11
4-263-387-21
3-703-244-00
4-263-389-01
PANEL, BACK (EX99: E2, E51)
PANEL, BACK (EX99: AR, MX)
PANEL, BACK (EX66/EX88)
BUSHING (2104), CORD
CASE (R), SIDE
FAN701
#1
1-855-006-11
7-685-647-71
FAN, DC
SCREW +BVTP 3X10 TYPE2 IT-3
Remark
51
HCD-EX66/EX88/EX99
6-2.
FRONT PANEL SECTION
57
56
55
57
54
58
59
53
57
not supplied
52
51
Note: If the wire (flat type) was replaced, fold it some as the
wire (flat type) before replacement.
Ref. No.
Part No.
Description
51
52
52
53
53
4-264-672-01
4-263-494-01
4-263-494-11
4-263-426-01
4-263-426-21
CUSHION (FOOT)
KNOB (VOL) (EX88/EX99)
KNOB (VOL) (EX66)
WINDOW (EX99)
WINDOW (EX88)
53
54
54
55
56
4-263-426-41
X-2560-700-2
X-2560-702-3
1-839-177-21
A-1800-425-A
WINDOW (EX66)
PANEL SUB ASSY, FRONT (EX88/EX99)
PANEL SUB ASSY, FRONT (EX66)
CABLE, FLEXIBLE FLAT (7 CORE)
PANEL BOARD, COMPLETE (EX99: E2, E51, AR)
56
A-1800-426-A
PANEL BOARD, COMPLETE (EX99: MX)
52
Remark
Ref. No.
Part No.
Description
Remark
56
56
56
56
56
A-1800-428-A
A-1800-429-A
A-1800-432-A
A-1800-433-A
A-1800-434-A
PANEL BOARD, COMPLETE (EX66: EA)
PANEL BOARD, COMPLETE (EX66: E4)
57
58
59
59
59
3-087-053-01
1-839-169-21
1-832-875-21
1-839-178-21
1-839-179-21
+BVTP2.6 (3CR)
CABLE, FLEXIBLE FLAT (21 CORE) (EX66)
HCD-EX66/EX88/EX99
6-3.
TOP PANEL SECTION
102
101
101
106
not supplied
105
not supplied
(LOADING board)
108
109
107
(including sled motor (M402),
spidle motor (M401))
104
115
116
108
109
108
109
114
113
included in 107
(spindle motor (M401))
108
109
114
110
113
111
S001
included in 107
(sled motor (M402))
112
103
#1
Ref. No.
Part No.
Description
101
102
103
104
105
3-253-143-01
4-120-662-01
4-263-391-02
1-839-176-21
A-1800-608-A
SCREW (B2.6), (+) P TAPPING
LID, TOP
PANEL, TOP
CDM76B ASSY
106
0 107
108
109
4-120-079-01
1-856-037-11
4-227-549-11
4-227-045-31
BELT (CDM76)
OPTICAL PICK-UP (DA11MMVGP)
INSULATOR
SPRING (INSULATOR), COIL
Remark
Ref. No.
Part No.
Description
110
111
112
113
114
4-985-672-01
1-834-268-21
A-1800-258-A
3-087-053-01
4-231-151-01
SCREW (+PTPWH M2.6), FLOATING
WIRE (FLAT TYPE) (16 CORE)
BD76 BOARD, COMPLETE
+BVTP2.6 (3CR)
STOPPER (BU)
115
116
S001
#1
3-080-204-31
4-166-292-01
1-771-853-11
7-685-647-71
SCREW, TAPPING, P2
SHAFT (SUPPORT)
SWITCH, DETECTION (LIMIT)
Remark
53
HCD-EX66/EX88/EX99
6-4.
CHASSIS SECTION
EX66/EX88
not supplied
not supplied
(REGULATOR board)
(EX88/EX99)
152
EX99
not supplied
#1
#1
#1
#1
#1
#1
#1
#1
151
not supplied
153
not supplied
Ref. No.
Part No.
Description
151
151
151
151
A-1800-479-A
A-1800-481-A
A-1800-482-A
A-1800-483-A
152
A-1800-461-A
AMP SMPS BOARD, COMPLETE (EX99)
AMP SMPS BOARD, COMPLETE (EX66: EA)
AMP SMPS BOARD, COMPLETE
(EX66: EXCEPT EA)
EFX-MODULE BOARD, COMPLETE (EX99)
54
Remark
Ref. No.
Part No.
Description
152
152
A-1800-462-A
A-1800-463-A
152
153
#1
A-1822-267-A
4-264-672-01
7-685-647-71
EFX-MODULE BOARD, COMPLETE
(EX66: EXCEPT EA)
EFX-MODULE BOARD, COMPLETE (EX66: EA)
CUSHION (FOOT)
Remark
HCD-EX66/EX88/EX99
SECTION 7
ELECTRICAL PARTS LIST
Note:
• Due to standardization, replacements in
the parts list may be different from the
parts specified in the diagrams or the components used on the set.
• -XX and -X mean standardized parts, so
they may have some difference from the
original one.
• Items marked “*” are not stocked since
they are seldom required for routine service. Some delay should be anticipated
when ordering these items.
• CAPACITORS
uF: μF
• COILS
uH: μH
Ref. No.
• RESISTORS
All resistors are in ohms.
METAL: Metal-film resistor.
METAL OXIDE: Metal oxide-film resistor.
F: nonflammable
• SEMICONDUCTORS
In each case, u: μ, for example:
uA. . : μA. . , uPA. . , μPA. . ,
uPB. . : μPB. . , uPC. . , μPC. . ,
uPD. . : μPD. .
When indicating parts by reference number, please include the board name.
Part No.
Description
A-1800-482-A
A-1800-483-A
AMP SMPS BOARD, COMPLETE (EX66: EA)
AMP SMPS BOARD, COMPLETE
(EX66: EXCEPT EA)
*************************
Remark
7-685-647-71
Ref. No.
1-162-970-11
1-100-831-91
CERAMIC CHIP 0.01uF
CERAMIC CHIP 0.001uF
10%
2%
C603
C604
C606
1-131-664-91
1-162-964-11
1-131-664-91
CERAMIC CHIP 0.15uF
CERAMIC CHIP 0.15uF
10%
10%
10%
25V
50V
(EX66: EA)
10V
50V
10V
C607
C608
C609
C611
C613
1-162-923-11
1-162-923-11
1-100-597-91
1-104-658-91
1-126-933-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
47PF
47PF
0.1uF
100uF
100uF
5%
5%
10%
20%
20%
50V
50V
25V
10V
16V
C615
C620
C622
C624
C625
1-100-597-91
1-126-948-11
1-126-947-11
1-126-953-11
1-126-951-11
CERAMIC CHIP
ELECT
ELECT
ELECT
ELECT
0.1uF
100uF
47uF
2200uF
470uF
10%
20%
20%
20%
20%
25V
35V
35V
35V
35V
C626
C627
C628
C637
C638
1-126-951-11
1-126-951-11
1-126-951-11
1-137-198-81
1-137-198-81
ELECT
ELECT
ELECT
FILM
FILM
470uF
470uF
470uF
1uF
1uF
20%
20%
20%
5%
5%
35V
35V
35V
50V
50V
C639
C640
C641
C642
C643
1-137-198-81
1-137-198-81
1-162-966-11
1-162-966-11
1-162-966-11
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.0022uF
0.0022uF
0.0022uF
5%
5%
10%
10%
10%
50V
50V
50V
50V
50V
C644
C645
C646
C647
C648
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.0022uF
0.0022uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C649
C650
C651
C652
C653
1-164-227-11
1-164-227-11
1-164-227-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
0.022uF
0.022uF
0.022uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C654
C655
1-164-227-11
1-164-227-11
10%
10%
25V
25V
• Abbreviation
AR
: Argentina model
E2
E4
EA
MX
: Mexican model
The components identified by mark 0
or dotted line with mark 0 are critical for
safety.
Part No.
Description
C656
C657
C658
C659
C660
1-164-227-11
1-126-960-11
1-126-964-11
1-100-881-91
1-100-881-91
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.022uF
1uF
10uF
47uF
47uF
10%
20%
20%
20%
20%
25V
50V
50V
6.3V
6.3V
C661
C662
C663
C664
C665
1-162-964-11
1-162-964-11
1-162-964-11
1-162-964-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
10V
C666
C667
C668
C676
C677
1-165-908-11
1-165-908-11
1-165-908-11
1-162-974-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
0.01uF
0.001uF
10%
10%
10%
10%
10V
10V
10V
50V
50V
C678
C679
C700
C701
C702
1-162-974-11
1-162-964-11
1-126-941-11
1-126-964-11
1-100-597-91
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.01uF
0.001uF
470uF
10uF
0.1uF
10%
20%
20%
10%
50V
50V
25V
50V
25V
C703
C705
C706
C707
C708
1-126-947-11
1-100-597-91
1-126-964-11
1-100-597-91
1-126-947-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
47uF
0.1uF
10uF
0.1uF
47uF
20%
10%
20%
10%
20%
35V
25V
50V
25V
35V
C709
C710
C713
C714
C716
1-100-597-91
1-126-951-11
1-104-658-91
1-135-977-31
1-164-156-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.1uF
470uF
100uF
680uF
0.1uF
10%
20%
20%
20%
25V
35V
10V
10V
25V
C717
C718
C719
C720
C721
1-126-961-11
1-100-566-91
1-162-970-11
1-162-970-11
1-126-963-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
2.2uF
0.1uF
0.01uF
0.01uF
4.7uF
20%
10%
10%
10%
20%
50V
25V
25V
25V
50V
C902
C903
C905
C907
1-112-869-51
1-112-869-51
1-114-594-21
1-114-594-21
CERAMIC
CERAMIC
FILM
FILM
470PF
470PF
0.22uF
0.22uF
10%
10%
10%
10%
0 C907
1-116-397-21
FILM
0.33uF
C911
C912
C914
C916
1-113-925-11
1-113-925-11
1-114-347-22
1-112-869-51
CERAMIC
CERAMIC
ELECT(BLOCK)
CERAMIC
0.01uF
0.01uF
330uF
470PF
< CAPACITOR >
C600
C601
AMP SMPS (EX66)
0
0
0
0
0
0
0
0
Remark
250V
250V
250V
250V
(EX66: EA)
10%
250V
(EX66: EXCEPT EA)
20%
20%
20%
10%
250V
250V
450V
250V
55
HCD-EX66/EX88/EX99
AMP SMPS (EX66)
Ref. No.
Part No.
Description
C930
C931
C932
C934
0 C935
1-107-826-11
1-162-927-11
1-162-968-11
1-112-300-91
1-116-819-51
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
0.1uF
100PF
0.0047uF
4.7uF
560PF
10%
5%
10%
10%
5%
16V
50V
50V
10V
1KV
Remark
C937
0 C939
0 C941
C967
C969
1-107-909-11
1-116-393-11
1-114-160-91
1-114-994-11
1-112-244-11
ELECT
FILM
CERAMIC CHIP
ELECT
ELECT
47uF
0.0033uF
1uF
2200uF
2200uF
20%
5%
10%
20%
20%
50V
400V
100V
35V
25V
C971
C976
C977
C980
1-162-970-11
1-126-965-11
1-100-597-91
1-126-964-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
0.01uF
22uF
0.1uF
10uF
10%
20%
10%
20%
25V
50V
25V
50V
Ref. No.
Part No.
Description
Remark
< JUMPER RESISTOR >
JR600
JR601
JR602
JR603
JR605
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR607
1-216-864-11
SHORT CHIP
0
< COIL >
L602
L603
L604
L605
L606
1-456-680-11
1-456-680-11
1-456-680-11
1-456-680-11
1-457-078-11
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, AIR-CORE
10uH
10uH
10uH
10uH
L607
L608
L609
L700
0 L903
1-457-077-11
1-457-077-11
1-457-078-11
1-400-424-11
1-456-082-11
COIL, AIR-CORE
COIL, AIR-CORE
COIL, AIR-CORE
COIL, CHOKE
47uH
COIL, LINE FILTER
0 L904
L966
L967
1-456-082-11
1-457-878-65
1-457-578-11
COIL, LINE FILTER (EX66: EA)
COIL, CHOKE
2.2uH
COIL, CHOKE
10uH
< CONNECTOR >
CN600
CN700
CN901
1-568-838-11
1-564-506-11
1-564-321-00
CONNECTOR, FFC 21P
PLUG, CONNECTOR 3P
PIN, CONNECTOR (3.96mm PITCH) 2P
< DIODE >
D601
D700
D701
D702
D703
6-500-848-01
8-719-079-47
6-502-964-01
6-503-020-01
6-500-335-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2840-T112-1
RK36LF-A4
DZ2J047M0L
DZ2J082M0L
MC2838-T112-1
D704
0 D902
D930
D931
D932
6-502-964-01
8-719-077-77
6-503-040-01
6-503-044-01
6-503-036-01
DIODE
DIODE
DIODE
DIODE
DIODE
DZ2J047M0L
D3SB60F3
DZ2J300M0L
DZ2J360M0L
DZ2J220M0L
D933
D934
0 D938
D940
D941
6-503-032-01
6-503-030-01
6-500-241-01
8-719-063-74
8-719-083-71
DIODE
DIODE
DIODE
DIODE
DIODE
DZ2J180M0L
DZ2J160M0L
SARS03
D1NL20U-TR2
UDZSUSTE-1730B
D965
0 D967
6-501-849-01
6-503-458-01
DIODE FMX-22SL
DIODE RK49LF-T1
< PHOTO COUPLER >
0 PH930
< FUSE >
0 F901
0 F931
1-523-067-51
1-523-085-11
FUSE (T5AH/250V)
FUSE (T2.5A/250V)
6-600-276-01
PHOTO COUPLER PS2561AL1-1-V-W
< TRANSISTOR >
Q601
Q602
Q604
Q605
Q606
8-729-620-13
8-729-040-76
6-551-699-01
6-551-699-01
6-551-699-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
KTA1273-Y-AT
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
Q607
Q700
Q701
Q702
Q703
6-551-699-01
8-729-620-13
8-729-040-76
8-729-620-13
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
ISA1602AM1-T111-1EF
2SC4154TP-1EF
KTA1273-Y-AT
2SC4154TP-1EF
2SC4154TP-1EF
Q704
Q705
Q706
Q707
Q708
6-551-699-01
8-729-620-13
8-729-620-13
8-729-620-13
8-729-036-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
ISA1602AM1-T111-1EF
2SC4154TP-1EF
2SC4154TP-1EF
2SC4154TP-1EF
KTC3203Y-AT
Q709
Q711
Q712
Q930
Q970
8-729-620-13
8-729-038-23
8-729-620-13
8-729-056-46
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
RT1N141C-TP-1
2SC4154TP-1EF
2SC5053T100Q
2SC4154TP-1EF
< FERRITE BEAD >
FB600
FB601
1-414-594-11
1-414-594-11
INDUCTOR, FERRITE BEAD
< IC >
IC600
IC601
IC602
IC603
IC604
8-759-278-58
8-759-278-58
6-713-034-01
6-701-680-01
6-701-680-01
IC
IC
IC
IC
IC
NJM4558V-TE2
NJM4558V-TE2
KIA7812API-U/PF
PST3629NR
PST3629NR
IC700
IC701
IC702
IC703
0 IC930
6-712-613-01
6-713-032-01
6-713-793-01
6-712-617-01
6-716-855-01
IC
IC
IC
IC
IC
SI-3010KM-TLS
KIA7809API-U/PF
SI-3010KFEK
SI-8008TM-TLS
STR-Y6766
IC932
6-711-947-01
IC MM1431CURE
56
< RESISTOR >
R600
R601
R602
R603
R604
1-216-821-11
1-216-837-11
1-216-837-11
1-216-842-11
1-216-842-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
22K
22K
56K
56K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R605
R606
R607
R608
R609
1-216-837-11
1-216-837-11
1-216-842-11
1-216-842-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
56K
56K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
HCD-EX66/EX88/EX99
AMP SMPS (EX66)
Ref. No.
Part No.
Description
Part No.
Description
R611
R612
R613
R615
R616
1-216-825-11
1-216-829-11
1-216-829-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
4.7K
4.7K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
Ref. No.
R720
R721
R722
R723
R724
1-218-847-11
1-218-859-11
1-216-821-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
3.3K
1K
3.3
3.3
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R617
R618
R619
R620
R621
1-218-855-11
1-218-855-11
1-216-845-11
1-216-821-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
100K
1K
10K
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R725
R726
R727
R728
R729
1-216-791-11
1-216-791-11
1-216-791-11
1-216-833-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
10K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R625
R627
R628
R629
R630
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R730
R731
R732
R733
R734
1-216-809-11
1-216-809-11
1-216-821-11
1-216-821-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
1K
1K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R631
R632
R633
R634
R635
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
3.3
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R737
R738
R739
R740
R741
1-216-849-11
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
3.3
3.3
3.3
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R636
R637
R638
R639
R640
1-216-791-11
1-216-791-11
1-216-791-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R743
R744
R745
R746
R747
1-216-841-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R641
R642
R643
R644
R645
1-216-841-11
1-216-845-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
100K
220K
220K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R752
R753
0 R901
0 R933
0 R934
1-216-821-11
1-216-821-11
1-240-938-51
1-257-117-11
1-257-117-11
METAL CHIP
METAL CHIP
METAL
METAL
METAL
1K
1K
1.5M
0.33
0.33
5%
5%
5%
5%
5%
1/10W
1/10W
1/2W F
2W
F
2W
F
R646
R647
R648
R649
R663
1-216-849-11
1-216-849-11
1-216-849-11
1-216-864-11
1-218-879-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
220K
220K
220K
0
22K
5%
5%
5%
1/10W
1/10W
1/10W
0.5%
1/10W
R935
R936
R937
R938
R939
1-218-855-11
1-218-887-11
1-216-829-11
1-218-881-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
47K
4.7K
27K
100K
0.5%
0.5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R670
R671
R672
R673
R674
1-216-841-11
1-216-836-11
1-216-841-11
1-216-841-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
18K
47K
47K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R944
R945
R947
R965
R971
1-215-929-11
1-216-809-11
1-216-793-11
1-216-821-11
1-216-849-11
METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
4.7
1K
220K
5%
5%
5%
5%
5%
3W
F
1/10W
1/10W
1/10W
1/10W
R699
R700
R701
R702
R703
1-216-833-11
1-216-821-11
1-216-845-11
1-216-833-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
100K
10K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R972
R975
R976
R977
R978
1-216-864-11
1-216-864-11
1-218-871-11
1-218-883-11
1-218-863-11
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
10K
33K
4.7K
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
R704
R705
R706
R707
R708
1-216-829-11
1-216-829-11
1-216-829-11
1-218-875-11
1-218-875-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
4.7K
15K
15K
5%
5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R987
R989
R990
0 R991
0 R992
1-216-821-11
1-216-825-11
1-216-833-11
1-215-871-11
1-215-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL OXIDE
METAL OXIDE
1K
2.2K
10K
2.2K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1W
F
1W
F
R709
R710
R711
R712
R713
1-218-871-11
1-216-833-11
1-216-845-11
1-216-825-11
1-216-853-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100K
2.2K
470K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R995
0 R996
1-215-871-11
1-215-871-11
METAL OXIDE
METAL OXIDE
2.2K
2.2K
5%
5%
1W
1W
R715
R716
R717
R718
R719
1-218-871-11
1-218-881-11
1-218-883-11
1-218-835-11
1-218-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
27K
33K
330
470
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
F
F
< TRANSFORMER >
0 T901
1-445-950-11
TRANSFORMER, CONVERTER
< TERMINAL BOARD >
TB600
1-694-785-11
TERMINAL BOARD (4P) (SPEAKERS)
57
HCD-EX66/EX88/EX99
AMP SMPS (EX66)
Ref. No.
Part No.
AMP SMPS (EX88)
Description
Remark
Ref. No.
Part No.
Description
C667
C668
C669
C676
C677
1-165-908-11
1-165-908-11
1-165-908-11
1-162-974-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
1uF
0.01uF
0.001uF
10%
10%
10%
10%
10V
10V
10V
50V
50V
C902
C903
C905
C907
C909
1-112-869-51
1-112-869-51
1-114-594-21
1-116-397-21
1-112-870-51
CERAMIC
CERAMIC
FILM
FILM
CERAMIC
470PF
470PF
0.22uF
0.33uF
0.001uF
10%
10%
10%
10%
20%
250V
250V
250V
250V
250V
0 C911
0 C912
0 C914
C930
0 C931
1-113-925-11
1-113-925-11
1-114-347-22
1-162-962-11
1-117-815-11
CERAMIC
CERAMIC
ELECT(BLOCK)
CERAMIC CHIP
FILM
0.01uF
0.01uF
330uF
470PF
0.001uF
20%
20%
20%
10%
3%
250V
250V
450V
50V
1.5KV
0 C932
C933
C934
C935
C936
1-114-160-91
1-162-960-11
1-107-904-11
1-164-227-11
1-162-962-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
1uF
220PF
3.3uF
0.022uF
470PF
10%
10%
20%
10%
10%
100V
50V
50V
25V
50V
0 C937
C938
0 C939
C943
C944
1-128-562-11
1-162-968-11
1-116-393-11
1-128-963-11
1-128-963-11
ELECT
CERAMIC CHIP
FILM
ELECT
ELECT
47uF
0.0047uF
0.0033uF
1000uF
1000uF
20%
10%
5%
20%
20%
100V
50V
400V
50V
50V
C946
C947
C950
C966
0 C967
1-100-597-91
1-165-895-91
1-126-965-91
1-107-826-11
1-117-220-81
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC
0.1uF
0.1uF
22uF
0.1uF
150PF
10%
10%
20%
10%
5%
25V
50V
50V
16V
2KV
C968
C969
C970
0 C971
C972
1-116-078-11
1-112-300-91
1-162-968-11
1-107-930-91
1-162-960-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
1uF
4.7uF
0.0047uF
22uF
220PF
10%
10%
10%
20%
10%
50V
10V
50V
100V
50V
0 C975
C977
C982
C983
C986
1-112-470-11
1-100-756-91
1-162-970-11
1-100-597-91
1-112-232-11
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
470PF
0.047uF
0.01uF
0.1uF
2700uF
10%
10%
10%
10%
20%
500V
50V
25V
25V
16V
C989
1-126-965-91
ELECT
22uF
20%
50V
< THERMISTOR >
0 TH902
1-811-315-31
POWER THERMISTOR
< VARISTOR >
0 VDR901 1-802-839-11 VARISTOR
*************************************************************
A-1800-481-A
*************************
7-685-647-71
< CAPACITOR >
0
0
0
0
0
Remark
C600
C604
C605
C607
C608
1-162-970-11
1-137-189-11
1-137-189-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
FILM
FILM
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.18uF
0.18uF
47PF
47PF
10%
5%
5%
5%
5%
25V
50V
50V
50V
50V
C609
C610
C612
C613
C614
1-100-597-91
1-126-957-11
1-104-658-91
1-126-933-11
1-100-597-91
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.1uF
0.22uF
100uF
100uF
0.1uF
10%
20%
20%
20%
10%
25V
50V
10V
16V
25V
C619
C620
C624
C625
C626
1-126-933-11
1-162-964-11
1-126-947-11
1-128-550-11
1-126-971-11
ELECT
CERAMIC CHIP
ELECT
ELECT
ELECT
100uF
0.001uF
47uF
2200uF
470uF
20%
10%
20%
20%
20%
16V
50V
35V
50V
50V
C627
C628
C629
0 C638
0 C639
1-126-971-11
1-126-971-11
1-126-971-11
1-135-618-11
1-135-618-11
ELECT
ELECT
ELECT
MYLAR
MYLAR
470uF
470uF
470uF
1uF
1uF
20%
20%
20%
5%
5%
50V
50V
50V
63V
63V
0 C640
0 C641
C642
C643
C644
1-135-618-11
1-135-618-11
1-162-966-11
1-162-966-11
1-162-966-11
MYLAR
MYLAR
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.0022uF
0.0022uF
0.0022uF
5%
5%
10%
10%
10%
63V
63V
50V
50V
50V
C645
C646
C647
C648
C649
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.0022uF
0.0022uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C650
C651
C652
C653
C654
1-164-227-11
1-164-227-11
1-164-227-11
1-164-227-11
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
0.022uF
0.022uF
0.022uF
10%
10%
10%
10%
10%
25V
25V
25V
25V
25V
C655
C656
C657
C658
C659
1-164-227-11
1-164-227-11
1-164-227-11
1-126-960-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.022uF
0.022uF
0.022uF
1uF
10uF
10%
10%
10%
20%
20%
25V
25V
25V
50V
50V
D601
0 D901
D930
D931
D932
6-500-848-01
8-719-510-53
6-503-040-01
6-502-961-01
6-503-040-01
DIODE
DIODE
DIODE
DIODE
DIODE
MC2840-T112-1
D4SB60L
DZ2J300M0L
DA2J10100L
DZ2J300M0L
C660
C661
C662
C663
C664
1-100-881-91
1-100-881-91
1-162-964-11
1-162-964-11
1-162-964-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
0.001uF
0.001uF
0.001uF
20%
20%
10%
10%
10%
6.3V
6.3V
50V
50V
50V
D934
D935
D937
D938
D939
6-502-976-01
6-502-961-01
6-502-967-01
6-502-961-01
6-502-961-01
DIODE
DIODE
DIODE
DIODE
DIODE
DZ2J150M0L
DA2J10100L
DZ2J06200L
DA2J10100L
DA2J10100L
C665
C666
1-162-964-11
1-165-908-11
CERAMIC CHIP 1uF
10%
10%
50V
10V
0 D940
D941
6-500-241-01
8-719-063-74
DIODE SARS03
DIODE D1NL20U-TR2
58
< CONNECTOR >
CN600
CN601
CN901
1-568-838-11
1-842-646-11
1-564-321-00
CONNECTOR, FFC 21P
CONNECTOR, BOARD TO BOARD 16P
< DIODE >
HCD-EX66/EX88/EX99
AMP SMPS (EX88)
Ref. No.
Part No.
Description
Part No.
Description
D943
D944
D967
D968
D969
6-501-849-01
6-503-032-01
6-502-961-01
6-503-036-01
6-503-032-01
DIODE
DIODE
DIODE
DIODE
DIODE
FMX-22SL
DZ2J180M0L
DA2J10100L
DZ2J220M0L
DZ2J180M0L
Remark
Ref. No.
Q604
Q605
Q606
Q607
Q608
6-551-699-01
6-551-699-01
6-551-699-01
6-551-699-01
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
2SC4154TP-1EF
D970
D972
0 D975
0 D981
D984
8-719-063-74
6-503-036-01
6-502-234-01
6-503-458-01
8-719-083-71
DIODE
DIODE
DIODE
DIODE
DIODE
D1NL20U-TR2
DZ2J220M0L
EG01C LF-F7
RK49LF-T1
UDZSUSTE-1730B
Q930
Q932
Q933
Q934
Q935
8-729-620-13
6-551-678-01
8-729-038-42
8-729-620-13
8-729-038-42
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
2SA1364-T111-1DE
RT1N441M-TP-1
2SC4154TP-1EF
RT1N441M-TP-1
D985
6-500-335-01
DIODE MC2838-T112-1
Q965
8-729-056-46
TRANSISTOR 2SC5053T100Q
< RESISTOR >
< FUSE >
0 F901
1-523-067-51
FUSE (T5AH/250V)
< IC >
IC600
IC601
IC602
IC603
0 IC931
8-759-278-58
8-759-278-58
6-712-613-01
6-701-680-01
6-716-854-01
IC
IC
IC
IC
IC
IC932
0 IC965
IC966
6-711-947-01
6-714-671-01
6-711-947-01
IC MM1431CURE
IC STR-Y6763
IC MM1431CURE
NJM4558V-TE2
NJM4558V-TE2
SI-3010KM-TLS
PST3629NR
STR-X6768N
< JUMPER RESISTOR >
JR600
JR601
JR602
JR603
JR604
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR605
JR606
JR607
JR608
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
< COIL >
L602
L603
L604
L605
L606
1-456-680-11
1-456-680-11
1-456-680-11
1-456-680-11
1-457-078-11
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, AIR-CORE
L607
L608
L609
0 L901
0 L902
1-457-077-11
1-457-077-11
1-457-078-11
1-460-371-11
1-460-371-11
COIL, AIR-CORE
COIL, AIR-CORE
COIL, AIR-CORE
COIL, LINE FILTER
COIL, LINE FILTER
L930
L969
1-457-878-65
1-457-578-11
COIL, CHOKE
COIL, CHOKE
10uH
10uH
10uH
10uH
2.2uH
10uH
< PHOTO COUPLER >
0 PH930
0 PH931
0 PH965
6-600-276-01
6-600-276-01
6-600-276-01
< TRANSISTOR >
Q600
Q601
Q602
Q603
8-729-620-13
6-551-699-01
8-729-038-37
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Remark
2SC4154TP-1EF
ISA1602AM1-T111-1EF
RT1N141M-TP-1
2SC4154TP-1EF
R600
R601
R602
R603
R604
1-216-821-11
1-216-835-11
1-216-835-11
1-216-841-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
15K
15K
47K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R606
R607
R608
R609
R610
1-216-835-11
1-216-835-11
1-216-841-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
15K
47K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R611
R612
R613
R614
R615
1-216-825-11
1-216-837-11
1-216-825-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
22K
2.2K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
0 R616
R617
R618
R619
R620
1-243-669-11
1-216-825-11
1-216-829-11
1-216-829-11
1-216-825-11
METAL
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0.05
2.2K
4.7K
4.7K
2.2K
5%
5%
5%
5%
5%
5W
F
1/10W
1/10W
1/10W
1/10W
R621
R622
R623
R624
R625
1-218-855-11
1-218-855-11
1-216-853-11
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
470K
22K
10K
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R626
R627
R628
R629
R630
1-218-895-11
1-218-871-11
1-218-871-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
3.3
3.3
0.5%
0.5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R631
R632
R633
R634
R635
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
3.3
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R636
R637
R638
R639
R640
1-216-791-11
1-216-837-11
1-216-837-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
22K
22K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R641
R642
R643
R644
R645
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
220K
220K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R646
R651
1-216-849-11
1-216-841-11
METAL CHIP
METAL CHIP
220K
47K
5%
5%
1/10W
1/10W
59
HCD-EX66/EX88/EX99
AMP SMPS (EX88)
Ref. No.
AMP SMPS (EX99)
Part No.
Description
R663
R670
R671
R672
R673
1-218-879-11
1-216-841-11
1-216-836-11
1-216-823-11
1-216-823-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
18K
1.5K
1.5K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R674
R675
R699
0 R901
0 R930
1-216-823-11
1-216-823-11
1-216-833-11
1-240-938-51
1-248-050-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL
METAL
1.5K
1.5K
10K
1.5M
0.22
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/2W F
2W
F
0 R931
R932
R933
R934
R935
1-248-050-11
1-216-813-11
1-218-823-11
1-216-832-11
1-216-797-11
METAL
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0.22
220
100
8.2K
10
5%
5%
0.5%
5%
5%
2W
F
1/10W
1/10W
1/10W
1/10W
R936
R937
R938
R939
R941
1-216-823-11
1-216-821-11
1-216-827-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.5K
1K
3.3K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R942
0 R943
0 R944
R945
R946
1-216-833-11
1-215-929-11
1-215-929-11
1-216-801-11
1-216-821-11
METAL CHIP
METAL OXIDE
METAL OXIDE
METAL CHIP
METAL CHIP
10K
100K
100K
22
1K
5%
5%
5%
5%
5%
1/10W
3W
F
3W
F
1/10W
1/10W
R947
R949
R950
R951
R954
1-216-827-11
1-218-867-11
1-216-821-11
1-216-837-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
3.3K
6.8K
1K
22K
0
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R956
R957
R958
R959
R960
1-216-837-11
1-218-863-11
1-218-859-11
1-218-879-11
1-218-855-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
4.7K
3.3K
22K
2.2K
5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R961
0 R965
0 R966
R967
R968
1-216-821-11
1-257-123-11
1-216-348-00
1-218-887-11
1-216-797-11
METAL CHIP
FUSIBLE
METAL OXIDE
METAL CHIP
METAL CHIP
1K
2.2
0.82
47K
10
5%
10%
5%
0.5%
5%
1/10W
1/2W F
1W
F
1/10W
1/10W
R969
R970
R971
R972
R973
1-216-829-11
1-216-845-11
1-218-875-11
1-218-847-11
1-218-271-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100K
15K
1K
2K
5%
5%
0.5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R974
R975
R977
R978
R979
1-216-824-11
1-216-824-11
1-216-830-11
1-216-793-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1.8K
1.8K
5.6K
4.7
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R980
R981
R984
R985
R986
1-216-821-11
1-218-871-11
1-216-813-11
1-218-863-11
1-218-863-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
220
4.7K
4.7K
5%
0.5%
5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R987
R988
R989
R992
0 R998
1-218-855-11
1-216-864-11
1-218-871-11
1-216-809-11
1-218-642-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL OXIDE
2.2K
0
10K
100
100K
0.5%
1/10W
0.5%
5%
5%
1/10W
1/10W
1W
F
Ref. No.
Part No.
Description
Remark
< TRANSFORMER >
0 T901
0 T903
1-445-952-11
1-445-951-11
TRANSFORMER, CONVERTER (MAIN)
TRANSFORMER, CONVERTER (SUB)
< TERMINAL BOARD >
TB600
1-694-785-11
< THERMISTOR >
0 TH902
1-811-315-31
POWER THERMISTOR
< VARISTOR >
0 VDR901 1-802-839-11 VARISTOR
*************************************************************
A-1800-479-A
*************************
7-685-647-71
< CAPACITOR >
60
C600
C601
C606
C607
C608
1-162-970-11
1-162-953-11
1-137-189-11
1-126-964-11
1-126-964-11
CERAMIC CHIP
CERAMIC CHIP
FILM
ELECT
ELECT
0.01uF
100PF
0.18uF
10uF
10uF
10%
5%
5%
20%
20%
25V
50V
50V
50V
50V
C609
C610
C611
C612
C613
1-126-964-11
1-126-964-11
1-137-189-11
1-100-597-91
1-162-964-11
ELECT
ELECT
FILM
CERAMIC CHIP
CERAMIC CHIP
10uF
10uF
0.18uF
0.1uF
0.001uF
20%
20%
5%
10%
10%
50V
50V
50V
25V
50V
C614
C615
C616
C617
C618
1-126-933-11
1-165-908-11
1-165-908-11
1-126-957-11
1-104-658-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
100uF
1uF
1uF
0.22uF
100uF
20%
10%
10%
20%
20%
16V
10V
10V
50V
10V
C625
C626
0 C627
0 C628
0 C629
1-126-947-11
1-104-661-91
1-128-555-91
1-128-555-91
1-128-555-91
ELECT
ELECT
ELECT
ELECT
ELECT
47uF
330uF
470uF
470uF
470uF
20%
20%
20%
20%
20%
35V
16V
63V
63V
63V
0 C630
0 C631
C633
C635
0 C640
1-128-555-91
1-135-632-51
1-165-908-11
1-165-908-11
1-135-618-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
MYLAR
470uF
2200uF
1uF
1uF
1uF
20%
20%
10%
10%
5%
63V
63V
10V
10V
63V
0 C641
0 C642
0 C643
C645
C646
1-135-618-11
1-116-866-91
1-116-866-91
1-126-972-11
1-126-972-11
MYLAR
MYLAR
MYLAR
ELECT
ELECT
1uF
1uF
1uF
1000uF
1000uF
5%
10%
10%
20%
20%
63V
100V
100V
50V
50V
C647
C648
C649
C650
C651
1-126-972-11
1-126-972-11
1-162-966-11
1-162-966-11
1-162-966-11
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1000uF
1000uF
0.0022uF
0.0022uF
0.0022uF
20%
20%
10%
10%
10%
50V
50V
50V
50V
50V
C652
C653
C654
C655
C656
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
1-162-966-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0022uF
0.0022uF
0.0022uF
0.0022uF
0.0022uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
HCD-EX66/EX88/EX99
AMP SMPS (EX99)
Ref. No.
Part No.
Description
C657
C658
C659
C660
C661
1-162-923-11
1-162-923-11
1-162-995-11
1-162-995-11
1-162-995-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
47PF
0.022uF
0.022uF
0.022uF
C662
C663
C664
C665
C666
1-162-995-11
1-162-995-11
1-162-995-11
1-162-995-11
1-162-995-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.022uF
0.022uF
0.022uF
0.022uF
0.022uF
C667
C668
C669
C670
C671
1-100-881-91
1-100-881-91
1-100-881-91
1-162-968-11
1-162-968-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
47uF
47uF
0.0047uF
0.0047uF
20%
20%
20%
10%
10%
6.3V
6.3V
6.3V
50V
50V
C672
C673
C674
C675
C676
1-162-968-11
1-162-968-11
1-162-968-11
1-162-968-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0047uF
0.0047uF
0.0047uF
0.0047uF
0.01uF
10%
10%
10%
10%
50V
50V
50V
50V
50V
C677
C678
0 C902
0 C903
0 C905
1-162-964-11
1-100-597-91
1-112-869-51
1-112-869-51
1-114-594-21
CERAMIC CHIP
CERAMIC CHIP
CERAMIC
CERAMIC
FILM
0.001uF
0.1uF
470PF
470PF
0.22uF
10%
10%
10%
10%
10%
50V
25V
250V
250V
250V
C907
C909
C910
C911
C912
1-116-397-21
1-112-870-51
1-112-866-51
1-113-925-11
1-113-925-11
FILM
CERAMIC
CERAMIC
CERAMIC
CERAMIC
0.33uF
0.001uF
100PF
0.01uF
0.01uF
10%
20%
10%
20%
20%
250V
250V
250V
250V
250V
0 C914
C930
0 C931
0 C932
C933
1-112-529-11
1-162-962-11
1-117-815-11
1-114-160-91
1-162-960-11
ELECT(BLOCK)
CERAMIC CHIP
FILM
CERAMIC CHIP
CERAMIC CHIP
390uF
470PF
0.001uF
1uF
220PF
20%
10%
3%
10%
10%
450V
50V
1.5KV
100V
50V
C934
C935
C936
0 C937
C938
1-107-904-11
1-164-227-11
1-162-962-11
1-128-562-11
1-162-968-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
3.3uF
0.022uF
470PF
47uF
0.0047uF
20%
10%
10%
20%
10%
50V
25V
50V
100V
50V
0 C939
0 C943
0 C944
C946
C947
1-116-393-11
1-137-901-21
1-137-901-21
1-100-597-91
1-165-895-91
FILM
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.0033uF
1000uF
1000uF
0.1uF
0.1uF
5%
20%
20%
10%
10%
400V
63V
63V
25V
50V
0 C950
C966
0 C967
C968
C969
1-128-551-11
1-107-826-11
1-117-220-81
1-116-078-11
1-112-300-91
ELECT
CERAMIC CHIP
CERAMIC
CERAMIC CHIP
CERAMIC CHIP
22uF
0.1uF
150PF
1uF
4.7uF
20%
10%
5%
10%
10%
63V
16V
2KV
50V
10V
C970
0 C971
C972
0 C975
C977
1-162-968-11
1-107-930-91
1-162-960-11
1-112-470-11
1-100-756-91
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC
CERAMIC CHIP
0.0047uF
22uF
220PF
470PF
0.047uF
10%
20%
10%
10%
10%
50V
100V
50V
500V
50V
C982
C983
C986
0 C989
1-162-970-11
1-100-597-91
1-112-232-11
1-128-551-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
0.01uF
0.1uF
2700uF
22uF
10%
10%
20%
20%
25V
25V
16V
63V
0
0
0
0
0
Remark
5%
5%
50V
50V
50V
50V
50V
50V
50V
50V
50V
50V
Ref. No.
Part No.
Description
Remark
< CONNECTOR >
CN600
CN601
CN602
CN901
1-784-784-11
1-842-646-11
1-842-797-11
1-564-321-00
CONNECTOR, FFC 23P
< DIODE >
D603
D604
0 D902
D930
D931
6-502-961-01
6-502-961-01
6-502-994-01
6-503-040-01
6-502-961-01
DIODE
DIODE
DIODE
DIODE
DIODE
DA2J10100L
DA2J10100L
D10XB60 F
DZ2J300M0L
DA2J10100L
D932
D934
D935
D937
D938
6-503-040-01
6-502-976-01
6-502-961-01
6-502-967-01
6-502-961-01
DIODE
DIODE
DIODE
DIODE
DIODE
DZ2J300M0L
DZ2J150M0L
DA2J10100L
DZ2J06200L
DA2J10100L
D939
0 D940
D941
D943
D944
6-502-961-01
6-500-241-01
8-719-063-74
6-501-849-01
6-503-032-01
DIODE
DIODE
DIODE
DIODE
DIODE
DA2J10100L
SARS03
D1NL20U-TR2
FMX-22SL
DZ2J180M0L
D967
D968
D969
D970
D972
6-502-961-01
6-503-036-01
6-503-032-01
8-719-063-74
6-503-036-01
DIODE
DIODE
DIODE
DIODE
DIODE
DA2J10100L
DZ2J220M0L
DZ2J180M0L
D1NL20U-TR2
DZ2J220M0L
0 D975
0 D981
D984
D985
6-502-234-01
6-503-458-01
8-719-083-71
6-500-335-01
DIODE
DIODE
DIODE
DIODE
EG01C LF-F7
RK49LF-T1
UDZSUSTE-1730B
MC2838-T112-1
< FUSE >
0 F901
1-523-042-51
FUSE (T6.3AH/250V)
< IC >
IC600
IC601
IC602
IC603
0 IC931
8-759-278-58
8-759-278-58
6-712-613-01
6-701-680-01
6-716-854-01
IC
IC
IC
IC
IC
NJM4558V-TE2
NJM4558V-TE2
SI-3010KM-TLS
PST3629NR
STR-X6768N
IC932
0 IC965
IC966
6-711-947-01
6-714-671-01
6-711-947-01
IC MM1431CURE
IC STR-Y6763
IC MM1431CURE
< JUMPER RESISTOR >
JR600
JR601
JR602
JR603
JR604
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR605
JR606
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
0
0
< COIL >
L601
L602
L603
L604
L605
1-456-680-11
1-456-680-11
1-456-680-11
1-456-680-11
1-457-078-11
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, CHOKE
COIL, AIR-CORE
10uH
10uH
10uH
10uH
61
HCD-EX66/EX88/EX99
AMP SMPS (EX99)
Ref. No.
Part No.
Description
L606
L607
L608
0 L901
0 L902
1-457-078-11
1-457-077-11
1-457-077-11
1-460-371-11
1-460-371-11
COIL, AIR-CORE
COIL, AIR-CORE
COIL, AIR-CORE
COIL, LINE FILTER
COIL, LINE FILTER
Remark
L930
L969
1-457-878-65
1-457-578-11
COIL, CHOKE
COIL, CHOKE
Ref. No.
Part No.
Description
R629
R630
0 R633
0 R634
R635
1-216-825-11
1-216-825-11
1-215-868-00
1-215-868-00
1-218-871-11
METAL CHIP
METAL CHIP
METAL OXIDE
METAL OXIDE
METAL CHIP
2.2K
2.2K
680
680
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1W
F
1W
F
1/10W
R636
R637
R638
R639
R643
1-218-871-11
1-218-871-11
1-218-871-11
1-216-837-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
22K
3.3
0.5%
0.5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R644
R645
R646
R647
R648
1-216-791-11
1-216-791-11
1-216-791-11
1-216-837-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
22K
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R649
R650
R651
R654
R655
1-216-791-11
1-216-791-11
1-216-791-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
220K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R656
R657
R658
R659
R661
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
220K
220K
220K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R663
R664
R665
R668
R669
1-218-877-11
1-216-849-11
1-216-849-11
1-216-805-11
1-216-805-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
18K
220K
220K
47
47
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R670
R671
R672
R673
R674
1-216-841-11
1-216-836-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
18K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R675
R676
R677
R678
R679
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R901
R914
R930
R931
R932
1-240-938-51
1-246-374-11
1-248-050-11
1-248-050-11
1-216-813-11
METAL
FUSIBLE
METAL
METAL
METAL CHIP
1.5M
0.1
0.22
0.22
220
5%
10%
5%
5%
5%
1/2W
1W
2W
2W
1/10W
R933
R934
R935
R936
R937
1-218-823-11
1-216-832-11
1-216-797-11
1-216-825-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
8.2K
10
2.2K
1K
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R938
R939
R941
R942
0 R943
1-216-827-11
1-216-825-11
1-216-833-11
1-216-833-11
1-215-929-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL OXIDE
3.3K
2.2K
10K
10K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
3W
F
0 R944
R945
R946
R947
R949
1-215-929-11
1-216-801-11
1-216-821-11
1-216-827-11
1-216-833-11
METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
22
1K
3.3K
10K
5%
5%
5%
5%
5%
3W
F
1/10W
1/10W
1/10W
1/10W
2.2uH
10uH
< PHOTO COUPLER >
0 PH930
0 PH931
0 PH965
6-600-276-01
6-600-276-01
6-600-276-01
< TRANSISTOR >
Q600
Q601
Q602
Q603
Q604
8-729-038-37
8-729-620-13
8-729-620-13
6-551-699-01
6-551-699-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
RT1N141M-TP-1
2SC4154TP-1EF
2SC4154TP-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
Q605
Q606
Q607
Q609
Q610
6-551-699-01
6-551-699-01
6-551-699-01
6-551-699-01
6-551-699-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
ISA1602AM1-T111-1EF
Q930
Q932
Q933
Q934
Q935
8-729-620-13
6-551-678-01
8-729-038-42
8-729-620-13
8-729-038-42
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
2SA1364-T111-1DE
RT1N441M-TP-1
2SC4154TP-1EF
RT1N441M-TP-1
Q965
8-729-056-46
TRANSISTOR 2SC5053T100Q
< RESISTOR >
R600
R601
R602
R603
R604
1-216-821-11
1-216-841-11
1-216-841-11
1-216-834-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
47K
47K
12K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R605
R606
R607
R608
R609
1-216-837-11
1-216-841-11
1-216-837-11
1-216-841-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
47K
22K
47K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R610
R611
R612
R613
R614
1-216-834-11
1-216-841-11
1-216-834-11
1-216-841-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
47K
12K
47K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R615
R616
R617
R618
R620
1-216-834-11
1-216-841-11
1-216-853-11
1-216-837-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
12K
47K
470K
22K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R621
R622
R623
R624
R625
1-216-833-11
1-218-855-11
1-218-855-11
1-218-895-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
2.2K
2.2K
100K
10K
5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R626
R627
0 R628
1-218-871-11
1-216-837-11
1-243-669-11
METAL CHIP
METAL CHIP
METAL
10K
22K
0.05
0.5%
5%
5%
1/10W
1/10W
5W
F
62
0
0
0
0
Remark
F
F
F
F
HCD-EX66/EX88/EX99
AMP SMPS (EX99)
Ref. No.
Part No.
Description
R950
R951
R954
R956
R957
1-216-821-11
1-216-837-11
1-216-864-11
1-216-837-11
1-218-863-11
METAL CHIP
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
1K
22K
0
22K
4.7K
5%
5%
1/10W
1/10W
Remark
5%
0.5%
R958
R959
R960
R961
0 R965
1-218-863-11
1-218-883-11
1-218-855-11
1-216-821-11
1-257-123-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
FUSIBLE
4.7K
33K
2.2K
1K
2.2
0 R966
R967
R968
R969
R970
1-216-348-00
1-218-887-11
1-216-797-11
1-216-829-11
1-216-845-11
METAL OXIDE
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R971
R972
R973
R974
R975
1-218-875-11
1-218-847-11
1-218-271-11
1-216-824-11
1-216-824-11
R977
R978
R979
R980
R981
Part No.
Description
1/10W
1/10W
C105
C106
C107
C108
C110
1-162-970-11
1-162-967-11
1-107-826-11
1-162-970-11
1-127-715-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.0033uF
0.1uF
0.01uF
0.22uF
10%
10%
10%
10%
10%
25V
50V
16V
25V
16V
0.5%
0.5%
0.5%
5%
10%
1/10W
1/10W
1/10W
1/10W
1/2W F
C111
C112
C113
C116
C117
1-164-227-11
1-107-826-11
1-107-826-11
1-117-681-11
1-100-756-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
0.022uF
0.1uF
0.1uF
100uF
0.047uF
10%
10%
10%
20%
10%
25V
16V
16V
16V
50V
0.82
47K
10
4.7K
100K
5%
0.5%
5%
5%
5%
1W
F
1/10W
1/10W
1/10W
1/10W
C118
C119
C120
C121
C122
1-107-826-11
1-117-681-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
16V
16V
16V
16V
16V
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
1K
2K
1.8K
1.8K
0.5%
0.5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C123
C124
C125
C126
C127
1-165-908-11
1-117-681-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
100uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
10V
16V
16V
16V
16V
1-216-833-11
1-216-793-11
1-216-821-11
1-216-821-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7
1K
1K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
C128
C129
C130
C131
C132
1-165-908-11
1-117-681-11
1-107-826-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
100uF
0.1uF
0.1uF
0.1uF
10%
20%
10%
10%
10%
10V
16V
16V
16V
16V
R984
R985
R986
R987
R988
1-216-813-11
1-218-863-11
1-218-863-11
1-218-855-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
220
4.7K
4.7K
2.2K
0
5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
C133
C201
C202
C204
C206
1-107-826-11
1-107-826-11
1-165-908-11
1-165-908-11
1-165-908-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
1uF
1uF
1uF
10%
10%
10%
10%
10%
16V
16V
10V
10V
10V
R989
R992
0 R998
1-218-871-11
1-216-809-11
1-218-642-11
METAL CHIP
METAL CHIP
METAL OXIDE
10K
100
100K
0.5%
5%
5%
1/10W
1/10W
1W
F
C207
C208
C209
C301
C302
1-117-681-11
1-162-964-11
1-107-826-11
1-128-394-11
1-107-826-11
ELECT CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
CERAMIC CHIP
100uF
0.001uF
0.1uF
220uF
0.1uF
20%
10%
10%
20%
10%
16V
50V
16V
10V
16V
C303
C304
C401
C402
C405
1-107-826-11
1-107-826-11
1-117-681-11
1-117-681-11
1-162-927-11
CERAMIC CHIP
CERAMIC CHIP
ELECT CHIP
ELECT CHIP
CERAMIC CHIP
0.1uF
0.1uF
100uF
100uF
100PF
10%
10%
20%
20%
5%
16V
16V
16V
16V
50V
C406
C407
C415
C416
C417
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
1-162-923-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47PF
47PF
47PF
47PF
47PF
5%
5%
5%
5%
5%
50V
50V
50V
50V
50V
C418
C901
C902
C903
C904
1-162-927-11
1-107-826-11
1-162-919-11
1-162-920-11
1-162-970-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.1uF
22PF
27PF
0.01uF
5%
10%
5%
5%
10%
50V
16V
50V
50V
25V
C905
C906
C907
C908
C909
1-162-927-11
1-162-927-11
1-162-927-11
1-162-927-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
100PF
100PF
100PF
0.1uF
5%
5%
5%
5%
10%
50V
50V
50V
50V
16V
C951
C952
C953
C955
1-162-910-11
1-162-910-11
1-165-884-11
1-165-884-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
5PF
5PF
2.2uF
2.2uF
0.25PF
0.25PF
10%
10%
50V
50V
6.3V
6.3V
< RELAY >
0 RY600
1-755-307-21
RELAY
< TRANSFORMER >
0 T901
0 T903
1-445-952-11
1-445-951-11
TRANSFORMER, CONVERTER (MAIN)
TRANSFORMER, CONVERTER (SUB)
< TERMINAL BOARD >
TB600
TB601
1-694-785-11
1-780-812-11
TERMINAL BOARD (2P) (SUBWOOFER)
< THERMISTOR >
0 TH902
1-811-315-31
POWER THERMISTOR
< VARISTOR >
0 VDR901 1-802-839-11 VARISTOR
*************************************************************
A-1800-258-A
BD76 BOARD, COMPLETE
*********************
< CAPACITOR >
C101
C102
C103
C104
1-162-968-11
1-162-970-11
1-107-826-11
1-107-826-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0047uF
0.01uF
0.1uF
0.1uF
10%
10%
10%
10%
50V
25V
16V
16V
Ref. No.
BD76
Remark
63
HCD-EX66/EX88/EX99
BD76
EFX-MODULE
Ref. No.
Part No.
Description
Remark
< CONNECTOR >
CN201
CN401
CN901
1-770-425-51
1-820-119-41
1-820-112-41
CONNECTOR, FFC/FPC 16P
< IC >
IC101
IC301
IC901
6-713-623-01
6-710-637-01
A-1768-193-A
IC LC786950T-US-H
IC BA5826HFP-E2
IC LC87F1JJ2AU-SQFP-H (for SERVICE)
< TRANSISTOR >
Q201
6-551-120-01
TRANSISTOR 2SA2119K
< RESISTOR >
R101
R102
R103
R104
R105
1-216-815-11
1-216-833-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
330
10K
0
0
0
5%
5%
1/10W
1/10W
R106
R107
R108
R109
R111
1-216-864-11
1-216-843-11
1-216-821-11
1-216-821-11
1-216-837-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
68K
1K
1K
22K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R112
R113
R114
R116
R117
1-216-864-11
1-216-819-11
1-216-819-11
1-216-843-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
680
680
68K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R118
R120
R121
R122
R123
1-216-809-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R124
R126
R129
R201
R202
1-216-833-11
1-216-864-11
1-216-809-11
1-218-446-11
1-216-789-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
0
100
1
2.2
5%
1/10W
5%
5%
5%
1/10W
1/10W
1/10W
R203
R301
R302
R303
R304
1-216-864-11
1-216-830-11
1-216-839-11
1-216-834-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
5.6K
33K
12K
10K
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
R416
R417
R901
R902
R903
1-216-809-11
1-216-295-91
1-216-809-11
1-216-809-11
1-216-857-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
0
100
100
1M
5%
1/10W
Remark
5%
5%
5%
1/10W
1/10W
1/10W
R904
R905
R906
R907
R908
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100
100
100
100
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R909
R910
R911
R912
R913
1-216-809-11
1-216-845-11
1-216-809-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
100
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R914
R922
R923
R924
R951
1-216-845-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
100
100
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R952
R953
R954
R955
1-216-835-11
1-216-803-11
1-216-803-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
15K
33
33
0
5%
5%
5%
1/10W
1/10W
1/10W
< VIBRATOR >
R305
R401
R402
R403
R404
1-216-832-11
1-216-295-91
1-216-295-91
1-216-809-11
1-216-809-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
8.2K
0
0
100
100
5%
1/10W
5%
5%
1/10W
1/10W
R405
R406
R407
R408
R409
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R411
R412
R413
R414
R415
1-216-809-11
1-216-864-11
1-216-864-11
1-216-809-11
1-216-809-11
METAL CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
100
0
0
100
100
5%
1/10W
5%
5%
1/10W
1/10W
64
X101
1-795-101-21 VIBRATOR, CERAMIC (16.934MHz)
X901
1-814-365-11 QUARTZ CRYSTAL UNITS (12MHz)
*************************************************************
A-1800-461-A
A-1800-462-A
A-1800-463-A
A-1822-267-A
EFX-MODULE BOARD, COMPLETE
(EX66: EXCEPT EA)
EFX-MODULE BOARD, COMPLETE (EX66: EA)
***************************
< CAPACITOR >
C800
1-100-567-81
CERAMIC CHIP 0.01uF
10%
C800
1-100-581-81
10%
C803
C804
C807
1-112-692-11
1-107-820-81
1-112-068-11
CERAMIC CHIP 1000PF
CERAMIC CHIP 0.1uF
CERAMIC CHIP 220PF
5%
C808
C809
C810
C811
C812
1-107-820-81
1-164-934-11
1-107-820-81
1-107-820-81
1-107-820-81
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
330PF
0.1uF
0.1uF
0.1uF
C813
C814
C815
C816
1-107-820-81
1-114-325-11
1-114-325-11
1-114-817-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
2.2uF
10%
10%
10%
C817
1-114-817-11
CERAMIC CHIP 2.2uF
10%
C820
C821
C824
1-114-325-11
1-114-325-11
1-114-817-11
CERAMIC CHIP 0.1uF
CERAMIC CHIP 0.1uF
CERAMIC CHIP 2.2uF
10%
10%
10%
C825
1-114-817-11
CERAMIC CHIP 2.2uF
10%
10%
10%
25V
(EX99)
50V
(EX66/EX88)
50V
16V
50V
16V
50V
16V
16V
16V
16V
25V
25V
50V
(EX66/EX88)
50V
(EX66/EX88)
25V
25V
50V
(EX66/EX88)
50V
(EX66/EX88)
HCD-EX66/EX88/EX99
EFX-MODULE
Ref. No.
Part No.
Description
C826
1-116-782-91
CERAMIC CHIP 2.2uF
10%
C827
1-116-782-91
CERAMIC CHIP 2.2uF
10%
C828
1-116-782-91
CERAMIC CHIP 2.2uF
10%
C829
1-116-782-91
CERAMIC CHIP 2.2uF
10%
Remark
Ref. No.
100V
(EX99)
100V
(EX99)
100V
(EX99)
100V
(EX99)
R815
R817
R818
R819
R820
< CONNECTOR >
CN801
CN802
CN803
1-842-455-11
1-842-458-11
1-842-458-11
< DIODE >
6-503-454-01
6-503-455-01
6-503-454-01
6-503-455-01
6-503-454-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMBJ54A-5 (EX99)
P6SMBJ40A-5 (EX88)
P6SMBJ54A-5 (EX99)
P6SMBJ40A-5 (EX88)
P6SMBJ54A-5 (EX99)
D806
D807
D807
D808
D809
6-503-455-01
6-503-454-01
6-503-455-01
6-503-543-01
6-503-543-01
DIODE
DIODE
DIODE
DIODE
DIODE
P6SMBJ40A-5 (EX88)
P6SMBJ54A-5 (EX99)
P6SMBJ40A-5 (EX88)
SS110R3 (EX66)
SS110R3 (EX66)
D810
D811
D815
D816
D817
6-503-543-01
6-503-543-01
6-500-335-01
6-500-335-01
6-500-848-01
DIODE
DIODE
DIODE
DIODE
DIODE
SS110R3 (EX66)
SS110R3 (EX66)
MC2838-T112-1 (EX66)
MC2838-T112-1 (EX66)
MC2840-T112-1 (EX88/EX99)
D818
D819
D820
6-500-848-01
6-500-848-01
6-500-848-01
DIODE MC2840-T112-1 (EX88/EX99)
DIODE MC2840-T112-1 (EX88/EX99)
DIODE MC2840-T112-1 (EX88/EX99)
Description
1-218-990-81
1-220-802-11
1-220-802-11
1-220-802-11
1-220-802-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
Remark
0
3.3
3.3
3.3
3.3
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R822
1-218-941-81 METAL CHIP
100
5%
1/16W
R823
1-218-941-81 METAL CHIP
100
5%
1/16W
R824
1-218-941-81 METAL CHIP
100
5%
1/16W
R825
1-218-941-81 METAL CHIP
100
5%
1/16W
*************************************************************
PIN HEADER 12P
PIN HEADER 6P
PIN HEADER 6P
D804
D804
D805
D805
D806
Part No.
PANEL
A-1800-425-A
A-1800-426-A
A-1800-428-A
A-1800-429-A
A-1800-432-A
PANEL BOARD, COMPLETE (EX66: EA)
A-1800-433-A
A-1800-434-A
PANEL BOARD, COMPLETE (EX66: E4)
**********************
< CAPACITOR >
< GROUND TERMINAL >
ET800
1-780-434-11
ET801
1-780-434-11
TERMINAL, GROUND (ON BOARD CONTACT)
(EX66: EA)
TERMINAL, GROUND (ON BOARD CONTACT)
(EX66: EA)
< IC >
IC800
IC800
IC800
6-716-817-01
6-716-818-01
6-716-819-01
IC TAS5630BPHDR (EX99)
IC TAS5613APHDR (EX88)
IC TAS5611APHDR (EX66)
< RESISTOR >
R800
R802
R806
R808
1-218-941-81
1-218-941-81
1-218-941-81
1-208-927-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
47K
5%
5%
5%
0.5%
R808
1-218-974-11
METAL CHIP
56K
5%
R809
R810
1-208-911-11
1-208-695-11
METAL CHIP
METAL CHIP
10K
3.3K
0.5%
0.5%
R810
1-208-909-11
METAL CHIP
8.2K
R811
R812
1-208-911-11
1-218-990-81
METAL CHIP
SHORT CHIP
10K
0
R813
R814
1-218-990-81
1-218-990-81
SHORT CHIP
SHORT CHIP
0 (EX99)
0 (EX66/EX88)
1/16W
1/16W
1/16W
1/16W
(EX99)
1/16W
(EX66/EX88)
1/16W
1/16W
(EX99)
0.5%
1/16W
(EX66/EX88)
0.5%
1/16W
C301
C308
C309
C318
C319
1-107-826-11
1-107-826-11
1-107-826-11
1-107-826-11
1-162-918-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
18PF
10%
10%
10%
10%
5%
16V
16V
16V
16V
50V
C320
C322
C323
C325
C328
1-162-919-11
1-107-826-11
1-107-826-11
1-162-964-11
1-126-157-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
22PF
0.1uF
0.1uF
0.001uF
10uF
5%
10%
10%
10%
20%
50V
16V
16V
50V
16V
C329
C331
C333
C335
C336
1-124-234-00
1-107-826-11
1-107-826-11
1-162-964-11
1-162-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22uF
0.1uF
0.1uF
0.001uF
0.001uF
20%
10%
10%
10%
10%
16V
16V
16V
50V
50V
C337
C342
C343
C344
C345
1-162-960-11
1-107-826-11
1-165-908-11
1-125-837-91
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
220PF
0.1uF
1uF
1uF
100uF
10%
10%
10%
10%
20%
50V
16V
10V
6.3V
10V
C353
C356
C359
C360
C361
1-162-964-11
1-126-518-11
1-164-315-11
1-164-315-11
1-162-966-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
470uF
470PF
470PF
0.0022uF
10%
20%
5%
5%
10%
50V
4V
50V
50V
50V
C362
C363
1-162-966-11
1-162-968-11
10%
10%
C363
1-164-173-11
10%
C364
1-162-968-11
10%
C364
1-164-173-11
10%
C365
C366
C367
C370
C371
1-124-234-00
1-125-837-91
1-165-908-11
1-125-837-91
1-125-837-91
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20%
10%
10%
10%
10%
16V
6.3V
10V
6.3V
6.3V
C372
1-125-837-91
CERAMIC CHIP 1uF
10%
6.3V
22uF
1uF
1uF
1uF
1uF
50V
50V
(EX99)
50V
(EX66/EX88)
50V
(EX99)
50V
(EX66/EX88)
65
HCD-EX66/EX88/EX99
PANEL
Ref. No.
Part No.
Description
Part No.
Description
C373
C374
C375
C376
C377
1-125-837-91
1-125-837-91
1-125-837-91
1-125-837-91
1-124-257-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1uF
1uF
1uF
1uF
2.2uF
10%
10%
10%
10%
20%
6.3V
6.3V
6.3V
6.3V
50V
Remark
C427
C428
C430
C431
C433
1-124-257-00
1-126-157-11
1-107-826-11
1-124-257-00
1-124-584-00
ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT
2.2uF
10uF
0.1uF
2.2uF
100uF
20%
20%
10%
20%
20%
C378
C379
C380
C381
C382
1-107-826-11
1-107-826-11
1-107-826-11
1-125-837-91
1-126-176-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
0.1uF
0.1uF
1uF
220uF
10%
10%
10%
10%
20%
16V
16V
16V
6.3V
10V
C434
1-137-189-11
FILM
0.18uF
5%
C435
1-137-189-11
FILM
0.18uF
5%
C384
C385
C388
C389
C390
1-107-826-11
1-165-908-11
1-124-584-00
1-124-257-00
1-164-227-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
0.1uF
1uF
100uF
2.2uF
0.022uF
10%
10%
20%
20%
10%
16V
10V
6.3V
50V
25V
C436
C437
C438
1-162-969-11
1-107-826-11
1-126-176-11
CERAMIC CHIP 0.1uF
ELECT
220uF
10%
10%
20%
C391
C392
C393
C395
C396
1-124-589-11
1-162-964-11
1-162-967-11
1-165-176-11
1-165-176-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
0.001uF
0.0033uF
0.047uF
0.047uF
20%
10%
10%
10%
10%
16V
50V
50V
16V
16V
C439
C440
C441
C442
C444
1-126-157-11
1-107-826-11
1-162-969-11
1-124-257-00
1-124-584-00
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
20%
10%
10%
20%
20%
16V
16V
25V
50V
10V
C445
C448
1-126-157-11
1-131-664-91
ELECT
10uF
CERAMIC CHIP 0.15uF
20%
10%
C449
1-131-664-91
CERAMIC CHIP 0.15uF
10%
C397
C398
C399
C401
1-165-176-11
1-165-176-11
1-107-826-11
1-137-652-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
0.047uF
0.1uF
0.039uF
10%
10%
10%
10%
C450
C451
1-126-157-11
1-162-968-11
ELECT
10uF
20%
10%
16V
10V
(EX66)
10V
(EX66)
16V
50V
C452
1-124-584-00
ELECT
20%
C401
1-164-677-11
10%
C454
1-162-964-11
10%
C456
C457
C458
1-107-826-11
1-162-964-11
1-162-964-11
CERAMIC CHIP 0.1uF
10%
10%
10%
10V
(EX99)
50V
(EX99)
16V
50V
50V
C459
C462
1-162-964-11
1-162-964-11
10%
10%
50V
50V
C402
1-137-652-91
10%
C402
1-164-677-11
10%
C405
1-137-652-91
10%
C405
1-164-677-11
10%
C406
1-137-652-91
10%
C406
1-164-677-11
10%
C408
C409
C410
C411
1-107-826-11
1-124-584-00
1-107-826-11
1-162-927-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.1uF
100uF
0.1uF
100PF
10%
20%
10%
5%
C412
1-124-257-00
ELECT
2.2uF
20%
C413
1-126-157-11
ELECT
10uF
20%
C416
1-165-908-11
CERAMIC CHIP 1uF
10%
C418
1-136-170-00
FILM
0.27uF
5%
C419
1-136-170-00
FILM
0.27uF
5%
C420
C421
1-162-927-11
1-165-112-11
CERAMIC CHIP 100PF
CERAMIC CHIP 0.33uF
5%
C422
1-104-509-11
10%
C423
1-124-589-11
ELECT
20%
C425
1-107-726-91
CERAMIC CHIP 0.01uF
10%
C426
1-124-257-00
ELECT
20%
66
47uF
2.2uF
16V
16V
16V
16V
(EX66/EX99)
16V
(EX88)
16V
(EX66/EX99)
16V
(EX88)
16V
(EX66/EX99)
16V
(EX88)
16V
(EX66/EX99)
16V
(EX88)
16V
10V
16V
50V
50V
(EX99)
16V
(EX99)
10V
(EX99)
50V
(EX99)
50V
(EX99)
50V
16V
(EX99)
16V
(EX99)
16V
(EX99)
16V
(EX99)
50V
Ref. No.
Remark
10uF
0.1uF
0.0068uF
2.2uF
100uF
100uF
50V
16V
16V
50V
10V
50V
(EX88/EX99)
50V
(EX88/EX99)
25V
16V
10V
< CONNECTOR >
CN301
CN302
CN303
CN304
CN305
1-779-544-21
1-784-727-11
1-779-289-11
1-819-866-11
1-568-850-11
CONNECTOR, FFC (LIF (NON-ZIF)) 7P
CONNECTOR, FFC 5P
CONNECTOR, FFC (LIF (NON-ZIF)) 21P
CONNECTOR, USB (A) 4P (USB)
CONNECTOR, FFC 7P
CN306
CN307
1-784-784-11
1-568-838-11
CONNECTOR, FFC 23P (EX99)
CONNECTOR, FFC 21P (EX66/EX88)
< DIODE >
D301
D302
D303
D305
D307
6-503-056-01
6-503-056-01
6-503-055-01
6-503-456-01
6-503-055-01
LED
LED
LED
LED
LED
1L0341Y23E0CA602-II (LCD BACK LIGHT)
1L0341Y23E0CA602-II (LCD BACK LIGHT)
1L434XA22E0DDT01 (VOLUME RING)
1L434XA22E0DD701 (DSGX)
1L434XA22E0DDT01 (VOLUME RING)
D309
D310
D311
D312
D313
6-503-055-01
6-503-456-01
6-502-961-01
8-719-058-24
8-719-058-24
LED 1L434XA22E0DDT01 (VOLUME RING)
LED 1L434XA22E0DD701 (EQ)
DIODE DA2J10100L
DIODE RB501V-40TE-17
DIODE RB501V-40TE-17
D315
D316
D318
D319
D324
6-500-334-01
8-719-058-24
6-502-961-01
6-500-848-01
6-500-848-01
DIODE
DIODE
DIODE
DIODE
DIODE
D325
D326
6-500-848-01
6-500-848-01
DIODE MC2840-T112-1
DIODE MC2840-T112-1
MC2836-T112-1
RB501V-40TE-17
DA2J10100L
MC2840-T112-1
MC2840-T112-1
HCD-EX66/EX88/EX99
PANEL
Ref. No.
Part No.
Description
Remark
< IC >
IC301
IC302
IC303
IC304
IC305
6-600-767-01
A-1826-385-A
8-759-598-69
6-714-881-01
8-759-278-58
IC
IC
IC
IC
IC
PNA4823M02S0 (IR)
LC87F7DJ2CVU-QIP-H (for SERVICE)
BA6956AN
MM1923DTRE
NJM4558V-TE2
IC306
IC307
IC308
6-713-384-01
6-701-680-01
8-759-359-49
IC BD3491FS-SE2
IC PST3629NR
IC NJM3414AV(TE2)
< JACK >
J301
J302
1-842-550-11
1-842-549-11
JACK BLOCK, PIN 2P (DVD/PC IN)
JACK (PHONES)
Ref. No.
Part No.
Description
R301
R304
R305
R306
R307
1-216-809-11
1-216-809-11
1-216-809-11
1-216-839-11
1-216-817-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
33K
470
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R308
R309
R310
R311
R314
1-216-809-11
1-216-807-11
1-216-807-11
1-216-803-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
68
68
33
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R315
R317
R318
R319
R320
1-216-803-11
1-216-807-11
1-216-821-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33
68
1K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R321
R322
R323
R324
R325
1-216-813-11
1-216-833-11
1-216-829-11
1-216-845-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220
10K
4.7K
100K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R326
R327
R328
R329
R330
1-216-845-11
1-216-817-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
470
100
100
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R331
R332
R333
R334
R335
1-216-809-11
1-216-829-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
10K
10K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R336
R337
R338
R339
R340
1-216-835-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
10K
10K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R341
R342
R343
R344
R345
1-216-829-11
1-216-832-11
1-216-821-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
8.2K
1K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R346
R347
R348
R349
R350
1-216-821-11
1-216-821-11
1-216-825-11
1-216-825-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
2.2K
2.2K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R351
R352
R353
R354
R355
1-216-809-11
1-216-829-11
1-216-829-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
4.7K
4.7K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R356
R357
R358
R359
R360
1-216-825-11
1-216-825-11
1-216-829-11
1-216-829-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
2.2K
4.7K
4.7K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R361
R362
R363
R364
R365
1-216-829-11
1-216-809-11
1-216-809-11
1-216-845-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
100
100K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
< JUMPER RESISTOR >
JR301
JR302
JR303
JR304
JR305
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR306
JR307
JR308
JR309
JR310
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
0
0
JR311
JR313
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
0
0
< LIQUID CRYSTAL DISPLAY >
ND301
1-811-042-11
DISPLAY PANEL, LIQUID CRYSTAL
< TRANSISTOR >
Q301
Q302
Q303
Q304
Q305
8-729-620-07
8-729-620-13
8-729-620-13
8-729-620-07
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052EF-T1-LEF
2SC4154TP-1EF
2SC4154TP-1EF
2SC3052EF-T1-LEF
2SC4154TP-1EF
Q308
Q309
Q310
Q311
Q312
8-729-620-13
6-551-699-01
8-729-620-13
6-551-699-01
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
ISA1602AM1-T111-1EF
2SC4154TP-1EF
ISA1602AM1-T111-1EF (EX99)
2SC4154TP-1EF (EX99)
Q313
Q314
Q315
Q316
Q317
8-729-620-13
8-729-620-13
8-729-620-13
8-729-620-13
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Q319
Q321
Q324
Q325
8-729-620-07
6-551-699-01
8-729-620-13
8-729-043-90
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3052EF-T1-LEF
ISA1602AM1-T111-1EF
2SC4154TP-1EF
IMX9T110
< RESISTOR >
R200
R201
R202
R203
R204
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-841-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
SHORT CHIP
METAL CHIP
0
0
0
0
47K
5%
1/10W
R300
1-216-839-11
METAL CHIP
33K
5%
1/10W
67
HCD-EX66/EX88/EX99
PANEL
Ref. No.
Part No.
Description
R366
R367
R368
R369
1-216-829-11
1-216-864-11
1-216-833-11
1-216-821-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
4.7K
0
10K
1K
5%
1/10W
Remark
5%
5%
R369
1-216-833-11
METAL CHIP
10K
5%
1/10W
1/10W
(EX66)
1/10W
(EX88)
R370
R371
1-216-837-11
1-216-833-11
METAL CHIP
METAL CHIP
22K
10K
5%
5%
R372
R373
R374
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
5%
5%
5%
R375
1-216-821-11
METAL CHIP
1K
5%
R375
1-216-825-11
METAL CHIP
2.2K
5%
R375
1-216-833-11
METAL CHIP
10K
5%
R375
1-216-837-11
METAL CHIP
22K
5%
R376
1-216-833-11
METAL CHIP
10K
5%
1/10W
(EA)
1/10W
(E4)
1/10W
(MX)
1/10W
(E2, E51, AR)
1/10W
R377
R378
R379
R380
R381
1-216-829-11
1-216-833-11
1-216-837-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
10K
22K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R382
R383
R384
R385
R386
1-216-839-11
1-216-833-11
1-216-839-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
10K
33K
10K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R387
R388
R389
1-216-833-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100
5%
5%
5%
1/10W
1/10W
1/10W
(EA)
R389
R390
1-216-864-11
1-216-809-11
SHORT CHIP
METAL CHIP
0 (EXCEPT EA)
100
5%
R390
R392
R393
R394
R396
1-216-864-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
SHORT CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0 (EXCEPT EA)
100
5%
100
5%
100
5%
10K
5%
1/10W
1/10W
1/10W
1/10W
R397
R398
R399
R400
R401
1-216-829-11
1-216-809-11
1-216-837-11
1-216-829-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
100
22K
4.7K
2.2K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R402
R403
R404
R405
R406
1-216-825-11
1-216-821-11
1-216-821-11
1-216-833-11
1-216-835-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
1K
1K
10K
15K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R407
R409
R410
R411
R412
1-216-835-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
10K
10K
10K
47K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R413
R414
R416
1-218-867-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
6.8K
47K
100K
0.5%
5%
5%
1/10W
1/10W
1/10W
68
1/10W
1/10W
(EX88/EX99)
1/10W
1/10W
1/10W
Ref. No.
Part No.
Description
R417
R418
R419
R420
R421
1-216-845-11
1-216-833-11
1-216-833-11
1-218-867-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
10K
6.8K
10K
5%
5%
5%
0.5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
Remark
R422
R423
R424
R425
R426
1-216-842-11
1-216-833-11
1-216-833-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
56K
10K
10K
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R427
1-216-838-11
METAL CHIP
27K
5%
R427
1-216-839-11
METAL CHIP
33K
5%
R427
1-216-840-11
METAL CHIP
39K
5%
R428
1-216-838-11
METAL CHIP
27K
5%
R428
1-216-839-11
METAL CHIP
33K
5%
1/10W
(EX99)
1/10W
(EX88)
1/10W
(EX66)
1/10W
(EX99)
1/10W
(EX88)
R428
1-216-840-11
METAL CHIP
39K
5%
R429
R430
R431
R432
1-216-841-11
1-216-841-11
1-216-843-11
1-216-789-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
47K
68K
2.2
5%
5%
5%
5%
1/10W
(EX66)
1/10W
1/10W
1/10W
1/10W
R433
R434
R435
R436
R437
1-216-829-11
1-216-789-11
1-216-821-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
2.2
1K
1K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R438
R439
R440
R441
1-216-845-11
1-216-817-11
1-216-837-11
1-216-836-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
470
22K
18K
5%
5%
5%
5%
R441
1-216-837-11
METAL CHIP
22K
5%
R442
R443
1-216-837-11
1-216-836-11
METAL CHIP
METAL CHIP
22K
18K
5%
5%
R443
1-216-837-11
METAL CHIP
22K
5%
R444
R445
1-216-813-11
1-216-813-11
METAL CHIP
METAL CHIP
220
220
5%
5%
R446
R447
1-216-864-11
1-216-841-11
SHORT CHIP
METAL CHIP
0
47K
5%
R448
1-216-841-11
METAL CHIP
47K
5%
R449
1-216-837-11
METAL CHIP
22K
5%
R451
1-216-821-11
METAL CHIP
1K
5%
R452
1-216-825-11
METAL CHIP
2.2K
5%
R453
1-216-821-11
METAL CHIP
1K
5%
R454
1-216-845-11
METAL CHIP
100K
5%
R455
1-216-821-11
METAL CHIP
1K
5%
R456
1-216-845-11
METAL CHIP
100K
5%
1/10W
(EA)
1/10W
1/10W
1/10W
1/10W
(EX99)
1/10W
(EX66/EX88)
1/10W
1/10W
(EX99)
1/10W
(EX66/EX88)
1/10W
1/10W
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
HCD-EX66/EX88/EX99
PANEL
Ref. No.
Part No.
Description
R458
1-216-837-11
METAL CHIP
22K
5%
Remark
Ref. No.
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
S312
S313
S314
S315
S316
R459
1-216-825-11
METAL CHIP
2.2K
5%
R460
1-216-833-11
METAL CHIP
10K
5%
R461
1-216-833-11
METAL CHIP
10K
5%
R462
1-218-867-11
METAL CHIP
6.8K
0.5%
R463
1-216-833-11
METAL CHIP
10K
5%
R464
1-216-845-11
METAL CHIP
100K
5%
R465
1-216-821-11
METAL CHIP
1K
5%
R466
1-216-821-11
METAL CHIP
1K
5%
R467
1-216-845-11
METAL CHIP
100K
5%
R468
1-216-821-11
METAL CHIP
1K
5%
R469
1-216-821-11
METAL CHIP
1K
5%
R470
1-216-845-11
METAL CHIP
100K
5%
R471
R472
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
4.7K
4.7K
5%
5%
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
1/10W
R473
R474
R475
R476
R477
1-216-833-11
1-216-174-00
1-216-837-11
1-216-829-11
1-216-839-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100
22K
4.7K
33K
5%
5%
5%
5%
5%
R478
R479
R480
R481
R482
1-216-174-00
1-216-845-11
1-216-829-11
1-216-821-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100K
4.7K
1K
47K
R484
R485
R486
R487
R488
1-216-821-11
1-216-845-11
1-216-825-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
R489
R491
R492
R493
R494
1-216-833-11
1-216-821-11
1-216-845-11
1-216-825-11
1-216-174-00
R495
R496
R497
R498
R499
1-216-833-11
1-216-829-11
1-216-839-11
1-216-174-00
1-216-833-11
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
1/10W
(EX99)
REGULATOR (EX88)
Part No.
Description
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
1-771-410-21
SWITCH, TACTILE (x)
SWITCH, TACTILE (REC TO USB)
SWITCH, TACTILE (DSGX)
SWITCH, TACTILE (ENTER)
SWITCH, TACTILE (TUNING+ M L)
Remark
< VIBRATOR >
X301
1-814-067-11 OSCILLATOR, CRYSTAL (32.768kHz)
X302
1-814-474-21 CERAMIC OSCILLATOR (20MHz)
*************************************************************
REGULATOR BOARD (EX88)
****************
7-685-647-71
< CAPACITOR >
C700
C701
C702
C703
C705
1-126-935-11
1-126-964-11
1-100-597-91
1-126-947-11
1-100-597-91
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
470uF
10uF
0.1uF
47uF
0.1uF
20%
20%
10%
20%
10%
16V
50V
25V
35V
25V
C706
C707
C708
C709
C710
1-126-964-11
1-100-597-91
1-126-947-11
1-100-597-91
1-126-935-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.1uF
47uF
0.1uF
470uF
20%
10%
20%
10%
20%
50V
25V
35V
25V
16V
1/10W
1/8W
1/10W
1/10W
1/10W
C713
C714
C716
C717
C718
1-104-658-91
1-135-977-31
1-164-156-11
1-126-961-11
1-100-597-91
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
680uF
0.1uF
2.2uF
0.1uF
20%
20%
20%
10%
10V
10V
25V
50V
25V
5%
5%
5%
5%
5%
1/8W
1/10W
1/10W
1/10W
1/10W
C719
C720
C721
1-162-970-11
1-162-970-11
1-126-963-11
CERAMIC CHIP 0.01uF
CERAMIC CHIP 0.01uF
ELECT
4.7uF
10%
10%
20%
25V
25V
50V
1K
100K
2.2K
47K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
1K
100K
2.2K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/8W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
4.7K
33K
100
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/8W
1/10W
< CONNECTOR >
CN700
* CN701
1-842-654-11
1-564-518-11
PLUG, CONNECTOR 3P
< DIODE >
D700
D701
D702
D703
D704
8-719-079-47
6-502-964-01
6-503-020-01
6-500-335-01
6-502-964-01
DIODE
DIODE
DIODE
DIODE
DIODE
RK36LF-A4
DZ2J047M0L
DZ2J082M0L
MC2838-T112-1
DZ2J047M0L
< FERRITE BEAD >
< SWITCH >
S301
S303
S304
S305
S306
1-771-410-21
1-771-410-21
1-786-417-11
1-771-410-21
1-771-410-21
SWITCH, TACTILE ("/1)
SWITCH, TACTILE (NX)
ENCODER, ROTARY (VOLUME)
SWITCH, TACTILE (Z)
SWITCH, TACTILE (FUNCTION)
S307
S308
S309
1-771-410-21
1-771-410-21
1-771-410-21
SWITCH, TACTILE (EQ)
SWITCH, TACTILE (OPTIONS)
SWITCH, TACTILE (TUNING– l m)
FB700
FB701
1-414-594-11
1-414-594-11
< IC >
IC700
IC701
IC702
IC703
6-712-613-01
6-713-032-01
6-713-793-01
6-712-617-01
IC
IC
IC
IC
SI-3010KM-TLS
KIA7809API-U/PF
SI-3010KFEK
SI-8008TM-TLS
< COIL >
L700
1-400-424-11
COIL, CHOKE
47uH
69
HCD-EX66/EX88/EX99
REGULATOR (EX88)
Ref. No.
Part No.
REGULATOR (EX99)
Description
Remark
Ref. No.
Part No.
< TRANSISTOR >
Remark
REGULATOR BOARD (EX99)
*****************
Q700
Q701
Q702
Q703
Q704
8-729-620-13
8-729-040-76
8-729-620-13
8-729-620-13
6-551-699-01
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
KTA1273-Y-AT
2SC4154TP-1EF
2SC4154TP-1EF
ISA1602AM1-T111-1EF
Q705
Q706
Q707
Q708
Q709
8-729-620-13
8-729-620-13
8-729-620-13
8-729-036-86
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
2SC4154TP-1EF
2SC4154TP-1EF
KTC3203Y-AT
2SC4154TP-1EF
Q711
8-729-038-23
TRANSISTOR RT1N141C-TP-1
7-685-647-71
< CAPACITOR >
< RESISTOR >
R700
R701
R702
R703
R704
1-216-821-11
1-216-829-11
1-216-833-11
1-216-829-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
4.7K
10K
4.7K
100K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R705
R706
R707
R708
R709
1-216-829-11
1-216-829-11
1-218-875-11
1-218-875-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
15K
15K
10K
5%
5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R710
R711
R712
R713
R715
1-216-833-11
1-216-845-11
1-216-825-11
1-216-853-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
2.2K
470K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R716
R717
R718
R719
R720
1-218-881-11
1-218-883-11
1-218-835-11
1-218-839-11
1-218-847-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
33K
330
470
1K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R721
R722
R723
R724
R725
1-218-859-11
1-216-821-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
1K
3.3
3.3
3.3
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R726
R727
R728
R729
R730
1-216-791-11
1-216-791-11
1-216-833-11
1-216-845-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
10K
100K
100
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R731
R732
R733
R734
R737
1-216-809-11
1-216-821-11
1-216-821-11
1-216-837-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
1K
1K
22K
220K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R738
R739
R740
R741
R742
1-216-791-11
1-216-791-11
1-216-791-11
1-216-791-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
3.3
3.3
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R743
1-216-821-11 METAL CHIP
1K
5%
1/10W
R744
1-216-837-11 METAL CHIP
22K
5%
1/10W
R745
1-216-837-11 METAL CHIP
22K
5%
1/10W
R746
1-216-837-11 METAL CHIP
22K
5%
1/10W
R747
1-216-837-11 METAL CHIP
22K
5%
1/10W
*************************************************************
70
Description
C700
C701
C702
C703
C705
1-126-935-11
1-126-964-11
1-100-597-91
1-126-947-11
1-100-597-91
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
470uF
10uF
0.1uF
47uF
0.1uF
20%
20%
10%
20%
10%
16V
50V
25V
35V
25V
C706
C707
C708
C709
C710
1-126-964-11
1-100-597-91
1-126-947-11
1-100-597-91
1-126-935-11
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
10uF
0.1uF
47uF
0.1uF
470uF
20%
10%
20%
10%
20%
50V
25V
35V
25V
16V
C713
C714
C716
C717
C718
1-104-658-91
1-135-977-31
1-164-156-11
1-126-961-11
1-100-597-91
ELECT
ELECT
CERAMIC CHIP
ELECT
CERAMIC CHIP
100uF
680uF
0.1uF
2.2uF
0.1uF
20%
20%
20%
10%
10V
10V
25V
50V
25V
C719
C720
C721
C722
C723
1-162-970-11
1-162-970-11
1-126-963-11
1-126-960-11
1-126-960-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
ELECT
0.01uF
0.01uF
4.7uF
1uF
1uF
10%
10%
20%
20%
20%
25V
25V
50V
50V
50V
C724
1-126-964-11
ELECT
10uF
20%
50V
< CONNECTOR >
CN700
* CN701
* CN702
1-842-654-11
1-794-042-11
1-564-518-11
PLUG, CONNECTOR 3P
< DIODE >
D700
D701
D702
D703
D704
8-719-079-47
6-502-964-01
6-503-020-01
6-500-335-01
6-502-964-01
DIODE
DIODE
DIODE
DIODE
DIODE
RK36LF-A4
DZ2J047M0L
DZ2J082M0L
MC2838-T112-1
DZ2J047M0L
D705
D706
6-500-848-01
6-500-848-01
DIODE MC2840-T112-1
DIODE MC2840-T112-1
< FERRITE BEAD >
FB700
FB701
1-414-594-11
1-414-594-11
< IC >
IC700
IC701
IC702
IC703
6-712-613-01
6-713-032-01
6-713-793-01
6-712-617-01
IC
IC
IC
IC
SI-3010KM-TLS
KIA7809API-U/PF
SI-3010KFEK
SI-8008TM-TLS
< COIL >
L700
1-400-424-11
COIL, CHOKE
47uH
< TRANSISTOR >
Q700
Q701
Q702
Q703
8-729-620-13
8-729-040-76
8-729-620-13
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC4154TP-1EF
KTA1273-Y-AT
2SC4154TP-1EF
2SC4154TP-1EF
HCD-EX66/EX88/EX99
REGULATOR (EX99)
Ref. No.
Part No.
Description
Q704
Q705
Q706
Q707
Q708
6-551-699-01
8-729-620-13
8-729-620-13
8-729-620-13
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
ISA1602AM1-T111-1EF
2SC4154TP-1EF
2SC4154TP-1EF
2SC4154TP-1EF
2SC4154TP-1EF
Remark
Q709
Q710
Q711
Q712
8-729-036-86
8-729-620-13
8-729-038-23
8-729-620-13
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
KTC3203Y-AT
2SC4154TP-1EF
RT1N141C-TP-1
2SC4154TP-1EF
Ref. No.
Part No.
Description
TUNER
Remark
R753
1-216-833-11 METAL CHIP
10K
5%
1/10W
*************************************************************
TUNER BOARD
************
< CAPACITOR >
< RESISTOR >
R700
R701
R702
R703
R704
1-216-821-11
1-216-833-11
1-216-845-11
1-216-829-11
1-216-829-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
100K
4.7K
4.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R705
R706
R707
R708
R709
1-216-829-11
1-216-829-11
1-218-875-11
1-216-841-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
15K
47K
10K
5%
5%
0.5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R710
R711
R712
R713
R715
1-216-833-11
1-216-845-11
1-216-825-11
1-216-853-11
1-218-871-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
100K
2.2K
470K
10K
5%
5%
5%
5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R716
R717
R718
R719
R720
1-218-881-11
1-218-883-11
1-218-835-11
1-218-839-11
1-218-847-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
33K
330
470
1K
0.5%
0.5%
0.5%
0.5%
0.5%
1/10W
1/10W
1/10W
1/10W
1/10W
R721
R722
R723
R724
R725
1-218-859-11
1-216-821-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
1K
3.3
3.3
3.3
0.5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R726
R727
R728
R729
R730
1-216-791-11
1-216-791-11
1-216-833-11
1-216-825-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
3.3
10K
2.2K
10K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R731
R732
R733
R734
R735
1-216-845-11
1-216-809-11
1-216-809-11
1-216-821-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
100
100
1K
1K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R736
R739
R740
R741
R742
1-216-821-11
1-216-849-11
1-216-791-11
1-216-791-11
1-216-791-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
220K
3.3
3.3
3.3
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R743
R744
R745
R746
R747
1-216-791-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3
22K
22K
22K
22K
5%
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
R748
R749
R750
R751
R752
1-216-821-11
1-216-837-11
1-218-875-11
1-216-841-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
22K
15K
47K
100K
5%
5%
0.5%
5%
5%
1/10W
1/10W
1/10W
1/10W
1/10W
C501
C502
C503
C504
C505
1-125-837-91
1-125-837-91
1-162-967-11
1-162-970-11
1-125-837-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
1uF
1uF
0.0033uF
0.01uF
1uF
10%
10%
10%
10%
10%
6.3V
6.3V
50V
25V
6.3V
C506
C511
C512
C513
C514
1-165-176-11
1-124-584-00
1-125-891-11
1-162-970-11
1-164-677-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.047uF
100uF
0.47uF
0.01uF
0.033uF
10%
20%
10%
10%
10%
16V
10V
10V
25V
16V
C516
1-125-891-11
CERAMIC CHIP 0.47uF
10%
10V
< CONNECTOR >
CN501
* CN502
1-568-850-11
1-506-680-11
CONNECTOR, FFC 7P
PLUG, CONNECTOR (2.5mm) 3P
(ANTENNA FM/AM)
< DIODE >
D501
D502
D503
6-501-579-01
6-501-579-01
6-501-579-01
DIODE MC2837
DIODE MC2837
DIODE MC2837
< BPF >
FL501
1-236-711-21
FILTER, BAND PASS
< IC >
IC501
IC502
6-716-080-01
6-716-361-01
IC S-815A33AMC-I2STFU
IC RS5B800-0002E2
< JUMPER RESISTOR >
JR501
JR502
JR510
1-216-864-11
1-216-864-11
1-216-864-11
SHORT CHIP
SHORT CHIP
SHORT CHIP
0
0
0
< COIL >
L501
L502
L503
1-457-998-11
1-481-524-11
1-481-521-11
COIL, AM ANTENNA
INDUCTOR
10uH
INDUCTOR
1uH
< RESISTOR >
R501
R502
R503
R504
R505
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT CHIP
100
100
100
10K
0
5%
5%
5%
5%
1/10W
1/10W
1/10W
1/10W
R506
R507
R508
R509
1-216-833-11
1-216-864-11
1-216-809-11
1-218-895-11
METAL CHIP
SHORT CHIP
METAL CHIP
METAL CHIP
10K
0
100
100K
5%
1/10W
5%
0.5%
1/10W
1/10W
< VIBRATOR >
X501
1-767-317-11 VIBRATOR, CRYSTAL (32.768kHz)
*************************************************************
71
HCD-EX66/EX88/EX99
Ref. No.
Part No.
Description
Remark
MISCELLANEOUS
**************
0
0
0
0
0
3
3
3
3
4
1-834-966-41
1-837-309-21
1-837-312-11
1-837-344-11
1-569-008-33
CORD, POWER-SUPPLY (E2, E4, E51)
CORD, POWER-SUPPLY (EA)
CORD, POWER-SUPPLY (AR)
CORD, POWER-SUPPLY (MX)
ADAPTOR, CONVERSION (E2, E4, E51)
55
58
59
59
59
1-839-177-21
1-839-169-21
1-832-875-21
1-839-178-21
1-839-179-21
1-839-176-21
1-856-037-11
1-834-268-21
1-855-006-11
1-771-853-11
OPTICAL PICK-UP (DA11MMVGP)
WIRE (FLAT TYPE) (16 CORE)
FAN, DC
SWITCH, DETECTION (LIMIT)
104
0 107
111
FAN701
S001
72
HCD-EX66/EX88/EX99
MEMO
73
HCD-EX66/EX88/EX99
REVISION HISTORY
Checking the version allows you to jump to the revised page.
Also, clicking the version at the top of the revised page allows you to jump to the next revised page.
Ver.
Date
1.0
2011.03
Description of Revision
New

hcd-ex99

Transcrição

Documentos relacionados

service manual